vinkodex.

KIA RIO JB common faults.

2005–2009. The fault list covers this generation and the engines in it. If the listing gives the exact version, pick it below.

What to watch for

What can go wrong on this car?

The list covers the generation, the engines and the transmissions. Once you pick the version, only the faults that apply to it stay.

This model has no fault write-up yet. That does not mean the model is fault-free. Write-ups go out after review.
Official recall2 recallsShow

The manufacturer fixes these for free at a franchised dealer. Ask with the VIN whether it was done. The list covers the whole generation. We did not filter it by model year. Some apply only to a narrower production window.

Most recent: 31 May 2012

12V244000AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVEAIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE31 May 2012 · NHTSA (USA)

KIA IS RECALLING CERTAIN MODEL YEAR 2006-2008 RIO VEHICLES, MANUFACTURED FROM FEBRUARY 20, 2005, THROUGH DECEMBER 9, 2007. THE FRONT PASSENGER SEAT OCCUPANT SENSOR MAT CAN EXPERIENCE FATIGUE CRACKING. IF SUFFICIENT CRACKING OCCURS, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) WILL CEASE TO FUNCTION SUCH THAT THE SYSTEM WILL NOT BE ABLE TO DETECT WHETHER A CHILD PASSENGER IS IN THE SEAT AND THE AIRBAG WILL DEPLOY DURING A CRASH NECESSITATING DEPLOYMENT.

Risk: AIR BAG DEPLOYMENT WITH A CHILD IN THE FRONT PASSENGER SIDE SEAT INCREASES THE RISK OF INJURY TO THAT CHILD.

Remedy: KIA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE OCS SEAT SENSOR MAT, FREE OF CHARGE. THE RECALL BEGAN ON JULY 26, 2012. OWNERS MAY CONTACT KIA CONSUMER ASSISTANCE CENTER AT 1-800-333-4542.

The authority's notice

05V557000CHILD SEATCHILD SEAT12 December 2005 · NHTSA (USA)

CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' CERTAIN CHILD RESTRAINT ANCHORS WILL NOT FULLY LATCH ONTO THE LOWER LATCH ANCHORS LOCATED BETWEEN THE REAR SEAT BACK AND REAR SEAT CUSHION BECAUSE OF INTERFERENCE BETWEEN THE CHILD SEAT ANCHORS AND A METAL WIRE LOCATED IN THE FRAME OF THE REAR SEAT BACK. UNTIL THE RECALL REPAIR IS COMPLETED, FOLLOW THE INSTRUCTIONS PROVIDED BY YOUR CHILD SEATS MANUFACTURER ON HOW TO PROPERLY INSTALL THE CHILD SEAT WITH YOUR VEHICLE'S REAR SAFETY BELTS RATHER THAN USING THE LATCH SYSTEM.

Risk: IN THE EVENT OF A VEHICLE CRASH, IF THE CHILD SEAT IS NOT PROPERLY INSTALLED, PERSONAL INJURY OR DEATH COULD OCCUR.

Remedy: DEALERS WILL REPLACE THE LOWER ANCHORS FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 30, 2006. OWNERS MAY CONTACT KIA AT 1-800-333-4542.

The authority's notice

Engines and transmissions in this generation

A fault is often tied to the engine, not to the whole generation. You find the engine code in the registration document.

JB · 2005–2009

Pick the version.

The fault list opens on the version page.

29 versions

Neighbouring generations

JB · 2005–2009

rio JB (2005-2009). If the listing is from the changeover year, look at the neighbour too.

Previous generation

This is the earliest.

This generation

JB · 2005–2009

Next generation

UB · 2011–2015

Common questions

About this generation

Which years does this page cover?

2005–2009. The changeover year can fall in two generations. If the listing is from that year, look at the neighbour too.

Does the fault apply to every car like this?

No. It depends on the engine and the transmission too.

Is it free?

The fault list is.

Information, not an expert opinion

We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.

  • A fault on the list does not mean the car you are looking at has it.
  • A fault missing from the list does not mean the model is fault-free. Write-ups are made model by model. Not all of them are done.
  • You decide whether to buy. This is no substitute for an inspection. That needs a workshop and a history check.
Details in the terms