Toyota Prius XW10 common faults.

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.

Risk: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.

Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

The authority's notice

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.

Risk: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.

Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

The authority's notice

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2001 THROUGH 2003 PRIUS PASSENGER CARS MANUFACTURED FROM JANUARY 28, 2000, THROUGH MAY 30, 2003. THE STEERING LINKAGE MAY LOOSEN, RESULTING IN REDUCED ELECTRIC STEERING ASSISTANCE WHEN MAKING A LEFT TURN.

Risk: LOSS OF POWER STEERING, PARTICULARLY WHEN AN OPERATOR IS ACTIVELY INTENDING TO STEER THE VEHICLE, MAY INCREASE THE RISK OF A CRASH.

Remedy: TOYOTA WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE NUTS IN THE STEERING LINKAGE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 8, 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

The authority's notice

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

Risk: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.

The authority's notice

ON CERTAIN PASSENGER VEHICLES, DUE TO IMPROPER MOLDING OF THE RESIN BODY OF THE CRANKSHAFT POSITION SENOR INSTALLED ON THE ENGINE BLOCK, ENGINE OIL MAY PENETRATE THE SEAL AND ENTER THE SENSOR WIRING CONNECTOR. THE WIRE HARNESS CONNECTOR MAY NOT BE SUFFICIENTLY ATTACHED TO THE LOCKING TAB OF THE SENSOR WIRING CONNECTOR.

Risk: ENGINE OIL INSIDE THE SENSOR WIRING CONNECTOR COULD CAUSE EXPANSION DUE TO THE HEAT OF THE ENGINE AND COULD DEFORM THE SENSOR WIRING CONNECTOR. THE CONNECTOR MAY BECOME DISCONNECTED, WHICH COULD CAUSE THE ENGINE TO STALL WHILE DRIVING AND NOT BE ABLE TO BE RESTARTED INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE CRANKSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON JULY 26, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

The authority's notice

THE INTERMEDIATE SHAFT AND SLIDING YOKE IN THE ELECTRIC POWER STEERING SYSTEM CAN CRACK WHEN LARGE FORCES ARE APPLIED AND THE CONNECTION MAY SEPARATE OR THE SLEEVE MAY FRACTURE.

Risk: THIS COULD RESULT IN A LOSS OF STEERING CONTROL OF THE VEHICLE.

Remedy: TOYOTA WILL REPLACE THE STEERING INTERMEDIATE SHAFT AND INSPECT THE SLIDING YOKE AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON JUNE 9, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

The authority's notice

CERTAIN PASSENGER VEHICLES MAY BE EQUIPPED WITH AN IMPROPERLY DESIGNED BRAKE LIGHT SWITCH. A SILICON OXIDE BUILD-UP OCCURS ON THE CONTACTS INSIDE THE BRAKE LIGHT SWITCH, WHICH CAN MAKE IT INOPERABLE.

Risk: IF THE SWITCH IS INOPERABLE, THE BRAKE LIGHTS WILL NOT ILLUMINATE AND CAN INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE BRAKE LIGHT SWITCH. THE RECALL BEGAN DURING DECEMBER 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.

The authority's notice

VEHICLE DESCRIPTION: PASSENGER VEHICLES. INSUFFICIENT ELECTRICAL CONTACT CAN OCCUR IN THE TORQUE SENSOR THAT CONTROLS THE POWER ASSIST OPERATION OF THE ELECTRIC POWER STEERING GEAR BOX. THE TORQUE SENSOR COULD SEND IMPROPER ELECTRICAL SIGNALS.

Risk: IF THIS OCCURS, THE POWER STEERING WARNING ICON WILL BE DISPLAYED ON THE CENTER PANEL, AND THE DRIVER COULD EXPERIENCE HIGHER THAN NORMAL STEERING EFFORT DEPENDING UPON VEHICLE SPEED.

Remedy: DEALERS WILL REPAIR THE ELECTRIC STEERING GEAR BOX.

The authority's notice