CAYA engine faults.

The EGR valve and its cooler block up with soot and oily deposits; the particulate filter cannot regenerate on short urban trips. The signs are reduced power, a warning light, and frequent regeneration. The software update after the diesel emissions affair made the EGR operate more often, which accelerated the phenomenon: the maker gave goodwill repairs in several cases.

On this engine the water pump is driven by the timing belt, and the plastic impeller of the pump, along with its electronically controlled shut-off ring, is the weak point: the ring sticks, and the impeller separates from the shaft or disintegrates. The first sign is slowly disappearing coolant and heating that stays cold for a long time. The real risk is not the price of the pump: the leaking water washes the grease off the timing belt rollers, and from then on the belt is what fails. If the timing belt snaps, the engine is badly damaged inside. That is why the two are always replaced together.

The internal springs of the flywheel tire, and the two discs knock against each other. The signs are a rattling or knocking from the bellhousing at idle and when releasing the clutch pedal, and vibration through the floor. If the clutch slips without a burnt smell, that also points to the flywheel. It is worth replacing in time: a disintegrated flywheel can destroy the bellhousing too. At a clutch replacement the two go together anyway.

The vanes of the variable geometry turbo are glued together by soot and oil arriving through the EGR. First you get overboost or a lack of boost, then loss of power above 2,000 rpm, and finally limp mode. Caught in time it is enough to remove the turbo, clean it and fit a new actuator rod. Short urban trips and gentle, low rev driving speed up the deposits.