vinkodex.

Mercedes-Benz A-Class A 180 Prestige common faults.

2012–2015, hatchback, petrol, 122 HP.

The fault list covers: M270DE16AL engine, MB6MT-MFA transmission.

What you save stays on this device only. My saves

4 fault write-ups. All are important. 2 recalls.

If you know the year, pick it. Faults for other years drop out of the list.

Before you buy

Known faults

4 important faults

critical2

Timing chain: the pulse wheel shifts, and the chain stretches with it

critical

The service life of the timing chain on this engine is not outstanding: it has to be replaced between 100 000 and 150 000 kilometres. The stretching, however, is accelerated by another part, and that is worth knowing.

Show the rest

The pulse wheel is press-fitted onto the camshaft, and it shifts a little with every start. That shifting significantly speeds up the stretching of the chain.

The symptom is difficulty starting, which can grow as far as complete failure. The engine starts hard when cold, and as the valve timing drifts it loses power.

The repair is therefore not just the chain: the stretched chain and the faulty pulse wheel have to be replaced together. If only the chain is renewed, the cause stays in place and the next chain stretches the same way. So look for both of them on the invoice.

On engines built before 2014 the phase regulators also failed quickly and started to crack. The maker revised them, which pushed the fault later, but did not eliminate it.

between 100,000 and 150,000 km

What to check

  • Start it cold: difficulty starting points to a stretched chain and a shifted pulse wheel
  • Ask for the invoice of the chain change and check whether the pulse wheel was replaced too
  • Listen to the engine cold: chain noise comes from the front of the engine
2 more steps in the write-up

Faulty weld seam on the camshaft: a recall, free replacement

critical

On engines built between July and September 2015 the supplier made a mistake in the welding process, so the weld seam on the camshaft is not as it should be. According to the authority's notice the fault affects individual M270 and M274 four-cylinder petrol engines.

Show the rest

On the affected cars the camshaft can break, and in doing so it damages the engine and shuts it off. The engine cannot then be restarted, the car comes to a halt, and in the words of the notice this increases the accident hazard.

As a precaution the maker prescribed replacement of the camshafts. The campaign started in November 2015, the target date for completion was the end of 2016, and the replacement is free for the owner.

At a purchase two things have to be cleared up: does the car fall into the production window, and if so, has the recall been carried out on it. The franchised dealer can answer that from the chassis number.

What to check

  • Check the production date of the engine: the examples from between July and September 2015 are affected
  • Ask whether the recall has been carried out, and ask for proof of it
  • If there is no proof, ask the franchised dealer with the chassis number: they can tell you
2 more steps in the write-up

expensive2

M274 2.0 turbo: crankcase ventilation (PCV) control valve failure

expensive

On the 2.0 turbo four cylinder (M274, and the transverse M270) the control valve of the crankcase ventilation system fails early. The official database holds 259 reports on it, almost exclusively on the 2015 to 2019 C 300 and GLC 300 versions.

Show the rest

The symptom: the engine warning light comes on, and diagnostics returns a fault code complaining about crankcase ventilation valve performance. Alongside it you get a fluctuating idle, a whistling or sucking noise from the engine bay, and sometimes harder starting.

The valve is part of the intake system, and if it sticks open or closed the engine either draws false air or the pressure in the crankcase rises. The latter pushes the crankshaft seals out, and from then on you have an oil leak. The valve itself is a cheap part, but getting to it is not always cheap.

On the same engine generation the complaints also include 27 reports of a cracked piston (weighted to the C 300 in 2015 and 2017). That is much rarer. If the engine burns oil or knocks, do not think only of the ventilation valve.

The official data is American, and the 2.0 petrol is far more common there than in Europe.

between 64,000 and 145,000 kmreported complaints only

What to check

  • Ask for a fault code read and look for the code on crankcase ventilation valve performance: that is the characteristic entry
  • Listen to the engine bay at idle: a whistling, sucking noise points to a torn valve diaphragm
  • Look around the valve cover and the crankshaft seals for oil leaks: the consequence of raised crankcase pressure
2 more steps in the write-up

M270: a failing electric thermostat leaves the engine cold

expensive

The electric thermostat can fail from 90 000 kilometres and sticks open. The coolant then circulates in the large circuit even while the engine should still be warming up, so the engine does not reach its 80 degree operating temperature.

Show the rest

The control unit logs it too: code P0128 means that the coolant temperature stays below the regulating temperature of the thermostat. The symptom is that the engine does not warm up properly even after a long time, the heater is lukewarm, consumption rises and the engine management light comes on as well.

An engine running cold for a long time wears faster, because cold oil does not lubricate the same way and fuel dilutes it in a greater proportion. The thermostat is built into the coolant circuit, so its replacement involves draining coolant.

above 90,000 km

What to check

  • Run the engine for ten minutes: the temperature gauge has to reach its usual middle value
  • Turn the heating on: the air should be hot, not lukewarm
  • Have the fault codes read and look for P0128
2 more steps in the write-up

Checklist

Mercedes-Benz A-Class A 180 Prestige

First what you would check on any car. Then the faults of this model.

Before you buy

Checklist

The printed sheet starts with what you would check on any car. What you tick stays on this device only.

On every car

Ask the owner

Faults of this model

vinkodex.com · Before you buy it, see what can go wrong.

Official recall2 recallsShow

The manufacturer fixes these for free at a franchised dealer. Ask with the VIN whether it was done.

Most recent: 1 September 2017

A12/1352/17Safety recallFire1 September 2017 · EU Safety Gate

The starter current limiter may be overloaded and overheat. As a consequence, the surrounding components could ignite, leading to a fire.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: 01/09/2017

The authority's notice

A12/00346/20Safety recallInjuriesno date · EU Safety Gate

The occupant classification system for the front passenger seat may not be calibrated in accordance with the specifications. Consequently, an installed child seat may be identified as a person or a small, light person as a child seat. As a result, the passenger airbag could be activated despite the presence of a child seat or the passenger airbag could fail to activate despite the presence of a person on the passenger seat, increasing the risk of injuries.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

Engine and transmission

M270DE16AL

90–115 kW (122–156 HP) · petrol

MB6MT-MFA · 6-speed manual, transverse (Mercedes F-SG 310 / 711.6xx)

manual · 6 speed

Torque limit310 Nm
MakerMercedes-Benz

We built the code from the model and the gear count. The factory sheet does not state it.

Variant data

What is in this version

Factory data

Trim
A 180 Prestige
Body
hatchback
Fuel
petrol
Transmission
manual
Engine size
1595 cc
Power
90 kW (122 HP)
Drive
FWD
Production
2012–2015

Factory service interval

The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.

  • Cabin (pollen) filter

    • 30,000 km or 2 years

  • Air filter

    • 60,000 km or 4 years

  • Brake fluid change

    • first: 3 years, then 2 years(first change at 3 years, then every two years)

  • Spark plugs, petrol

    • 60,000 km or 6 years
All W176 versions

Information, not an expert opinion

We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.

  • A fault on the list does not mean the car you are looking at has it.
  • A fault missing from the list does not mean the model is fault-free. Write-ups are made model by model. Not all of them are done.
  • You decide whether to buy. This is no substitute for an inspection. That needs a workshop and a history check.
Details in the terms