vinkodex.

Audi Allroad 45 TDI quattro common faults.

2019–2023, estate, diesel, 231 HP.

The fault list covers: DCPE engine, AL552 transmission.

What you save stays on this device only. My saves

1 fault write-ups. Important. No recall on the list.

If you know the year, pick it. Faults for other years drop out of the list.

Before you buy

Known faults

1 important faults

2.7 / 3.0 TDI V6: the rear timing chain and the oil pump drive

critical

The timing chain of the longitudinal V6 diesel runs at the back of the engine, on the gearbox side, so replacing it means taking out the engine or the gearbox. That alone makes it expensive, but the mechanism is the point: the chains stretch and the hydraulic tensioners lose their pressure. The first and only early sign is a 2 to 3 second metallic rattle audible on a cold start. If that is ignored, the chain jumps or breaks, and the engine is badly damaged inside. The same chain kit also drives the oil pump: if that seizes, the engine is left without lubrication.

What to check

  • Start it cold, in a quiet place, with the bonnet open: the rattle is audible in the first 2 to 3 seconds
  • Stand at the gearbox side of the engine: the noise comes from there, not from the front
  • Ask whether the chain and the tensioner were replaced, and ask for the invoice (it involves removing the engine)
3 more steps in the write-up

Checklist

Audi Allroad 45 TDI quattro

First what you would check on any car. Then the faults of this model.

Before you buy

Checklist

The printed sheet starts with what you would check on any car. What you tick stays on this device only.

On every car

Ask the owner

Faults of this model

vinkodex.com · Before you buy it, see what can go wrong.

Engine and transmission

DCPE

170 kW (231 HP) · diesel

AL552 · 8-speed automatic (longitudinal)

automatic · 8 speed

Torque limit700 Nm
MakerZF

We built the code from the model and the gear count. The factory sheet does not state it.

Variant data

What is in this version

Factory data

Trim
45 TDI quattro
Body
estate
Fuel
diesel
Transmission
automatic
Engine size
2967 cc
Power
170 kW (231 HP)
Drive
AWD
Production
2019–2023

Factory service interval

The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.

  • Air filter

    • 60,000 km or 4 years

  • Cabin (pollen) filter

    • 30,000 km or 2 years

  • Engine oil and oil filter

    • LongLife30,000 km or 2 years(valid only with LongLife-approved oil)
    • 15,000 km or 1 year

  • Brake fluid change

    • first: 3 years, then 2 years(first change at 3 years, then every two years)

  • Coolant (antifreeze) change

    • first: 193,000 km or 10 years, then 97,000 km or 5 years(G13 / G12++: first change at 120,000 miles or 10 years, then every 60,000 miles or 5 years)

  • Fuel filter, diesel

    • 60,000 km or 2 years
All B9.5 versions

Information, not an expert opinion

We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.

  • A fault on the list does not mean the car you are looking at has it.
  • A fault missing from the list does not mean the model is fault-free. Write-ups are made model by model. Not all of them are done.
  • You decide whether to buy. This is no substitute for an inspection. That needs a workshop and a history check.
Details in the terms