vinkodex.

Audi Allroad 3.0 TDI 190hp quattro Business Edition common faults.

2014–2018, estate, diesel, 190 HP.

The fault list covers: CZVF engine, DL501 transmission.

What you save stays on this device only. My saves

3 fault write-ups. All are important. 4 recalls.

If you know the year, pick it. Faults for other years drop out of the list.

Before you buy

Known faults

3 important faults

critical1

2.7 / 3.0 TDI V6: the rear timing chain and the oil pump drive

critical

The timing chain of the longitudinal V6 diesel runs at the back of the engine, on the gearbox side, so replacing it means taking out the engine or the gearbox. That alone makes it expensive, but the mechanism is the point: the chains stretch and the hydraulic tensioners lose their pressure. The first and only early sign is a 2 to 3 second metallic rattle audible on a cold start. If that is ignored, the chain jumps or breaks, and the engine is badly damaged inside. The same chain kit also drives the oil pump: if that seizes, the engine is left without lubrication.

What to check

  • Start it cold, in a quiet place, with the bonnet open: the rattle is audible in the first 2 to 3 seconds
  • Stand at the gearbox side of the engine: the noise comes from there, not from the front
  • Ask whether the chain and the tensioner were replaced, and ask for the invoice (it involves removing the engine)
3 more steps in the write-up

expensive2

Air suspension: compressor, air spring, ride height sensor

expensive

The four groups of parts in the air suspension (compressor, valve block, ride height sensors, air springs) work together, and any weak link causes a fault message, an uneven ride height or a car that settles. The characteristic symptom: the car sits down on one corner overnight, levels itself for minutes in the morning, and the compressor runs long and loud. According to the reports the compressor lasts 80,000 to 100,000 km; and a leaking air spring takes the compressor with it, because it keeps trying to make up the loss.

What to check

  • Look at the car cold, after standing a long time: has it settled on any corner
  • After startup time how long it takes to level, and listen to the compressor
  • Cycle through the ride height settings in the onboard menu and check that all of them work
3 more steps in the write-up

DL501 (7 speed S tronic): mechatronics and wet clutch

expensive

The 7 speed wet clutch S tronic used in the longitudinal engine Audis (0B5 / DL501) is more durable than the early DSG units, but the mechatronics unit is the most common source of faults here too. As the solenoids wear, the regulation of the hydraulic pressure deteriorates: harsh or missed shifts, delayed D/R engagement, and finally limp mode.

Show the rest

Alongside that, wear of the clutch pack gives shuddering and slipping when pulling away, and the dual mass flywheel rattles at idle. All three symptoms can appear together, and the fault code alone does not tell you which one is the trigger.

What to check

  • Pull away with a cold gearbox: there should be no shuddering and no clutch slip when setting off
  • Standing still, shift between D and R and watch the engagement delay: a 1 to 2 second hesitation is suspect
  • On the test drive go slowly through every gear, then under load too: the 2 to 3 shift should be smooth
2 more steps in the write-up

Checklist

Audi Allroad 3.0 TDI 190hp quattro Business Edition

First what you would check on any car. Then the faults of this model.

Before you buy

Checklist

The printed sheet starts with what you would check on any car. What you tick stays on this device only.

On every car

Ask the owner

Faults of this model

vinkodex.com · Before you buy it, see what can go wrong.

Official recall4 recallsShow

The manufacturer fixes these for free at a franchised dealer. Ask with the VIN whether it was done.

A12/00752/21Safety recallInjuriesno date · EU Safety Gate

The vehicles may be fitted with a towbar with a swivel mechanism that may have a defective locking pin. As a result, the pin could break while driving, increasing the risk of an accident.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/0264/19Safety recallInjuriesno date · EU Safety Gate

Due to contamination during its manufacture, the bonding of the components of the sunroof may be affected. Consequently there could be leaks in the sunroof or the rear glass panel could even detach.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/0382/19Safety recallFireno date · EU Safety Gate

In certain vehicles, fuel can leak onto the engine fuel rail. Fuel leakage close to a source of ignition may increase the risk of the vehicle catching fire.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/0862/19Safety recallInjuriesno date · EU Safety Gate

The locking mechanism in the articulated trailer hitch may be defective. Consequently, the trailer hitch might not be correctly locked and could swing out, causing the trailer to drop while the vehicle is in motion.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

Engine and transmission

CZVF · 3.0 TDI

140 kW (190 HP) · diesel

DL501 · 7-speed S tronic, longitudinal

DSG · 7 speed

Clutcholajfürdős
Torque limit550 Nm
MakerAudi

We built the code from the model and the gear count. The factory sheet does not state it.

Variant data

What is in this version

Factory data

Trim
quattro Business Edition
Body
estate
Fuel
diesel
Transmission
automatic
Engine size
2967 cc
Power
140 kW (190 HP)
Drive
AWD
Production
2014–2018

Factory service interval

The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.

  • Air filter

    • 60,000 km or 4 years

  • Cabin (pollen) filter

    • 30,000 km or 2 years

  • Engine oil and oil filter

    • LongLife30,000 km or 2 years(valid only with LongLife-approved oil)
    • 15,000 km or 1 year

  • Brake fluid change

    • first: 3 years, then 2 years(first change at 3 years, then every two years)

  • DSG oil change, WET clutch gearbox

    • 60,000 km or 4 years

  • Coolant (antifreeze) change

    • first: 193,000 km or 10 years, then 97,000 km or 5 years(G13 / G12++: first change at 120,000 miles or 10 years, then every 60,000 miles or 5 years)

  • Fuel filter, diesel

    • 60,000 km or 2 years
All C7 versions

Information, not an expert opinion

We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.

  • A fault on the list does not mean the car you are looking at has it.
  • A fault missing from the list does not mean the model is fault-free. Write-ups are made model by model. Not all of them are done.
  • You decide whether to buy. This is no substitute for an inspection. That needs a workshop and a history check.
Details in the terms