vinkodex.

Opel Astra 1.6i Edition common faults.

1998–2004, saloon, petrol, 85 HP.

The list covers this version.

What you save stays on this device only. My saves

1 fault write-ups. Important. 1 recalls.

If you know the year, pick it. Faults for other years drop out of the list.

Before you buy

Known faults

1 important faults

Easytronic: automated manual gearbox, clutch and shift actuator

expensive

The Opel Easytronic is not a conventional automatic: it is an ordinary manual gearbox in which electric actuators operate the clutch and change gear. There is no torque converter, and the drive breaks for a moment when it shifts.

Show the rest

The typical faults are: clutch and shift actuator failure, clutch wear, and lost adaptation values. Symptoms: jerking when pulling away, delayed or harsh shifts, an "F" warning, a stuck gear, and no creep.

Removal and refurbishment often come to 2,500 to 3,000 euro. On an old Corsa or Astra that can cost more than the car. A software update and an oil change sometimes help if it only jerks, but an actuator fault means replacing the part.

between 80,000 and 180,000 km2,500–3,000 EUR

What to check

  • Try it cold and warm: pulling away, creep, 1 to 2 and 2 to 3 shifts. Jerking or delay is suspect
  • Watch for the "F" or gearbox warning on the dash
  • Ask for a fault code read with Opel compatible diagnostics (not just generic OBD): actuator codes of the P1607 / P1728 / P1729 kind
3 more steps in the write-up

Checklist

Opel Astra 1.6i Edition

First what you would check on any car. Then the faults of this model.

Before you buy

Checklist

The printed sheet starts with what you would check on any car. What you tick stays on this device only.

On every car

Ask the owner

Faults of this model

vinkodex.com · Before you buy it, see what can go wrong.

Official recall1 recallsShow

The manufacturer fixes these for free at a franchised dealer. Ask with the VIN whether it was done.

Most recent: 1 December 2023

A12/01581/24Safety recallInjuries1 December 2023 · EU Safety Gate

The propellant used in the driver airbag inflator can degrade when exposed to very high temperatures and levels of humidity. If activated after an impact, excessive internal pressure may cause the inflator to burst, and metal fragments could pass through the cushion material causing injury to occupants. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: 01/12/2023

The authority's notice

Engine and transmission

No engine and transmission for this yet. When they are in, you see them here.

Variant data

What is in this version

Factory data

Trim
1.6i Edition
Body
saloon
Fuel
petrol
Transmission
manual
Engine size
1598 cc
Power
62 kW (84 HP)
Drive
FWD
Production
1998–2004

Factory service interval

The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.

  • Air filter

    • 60,000 km or 4 years

  • Cabin (pollen) filter

    • 30,000 km or 2 years

  • Brake fluid change

    • first: 3 years, then 2 years(first change at 3 years, then every two years)
All G versions

Information, not an expert opinion

We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.

  • A fault on the list does not mean the car you are looking at has it.
  • A fault missing from the list does not mean the model is fault-free. Write-ups are made model by model. Not all of them are done.
  • You decide whether to buy. This is no substitute for an inspection. That needs a workshop and a history check.
Details in the terms