vinkodex.

Volkswagen Beetle 2.0 TDI 150hp BMT Sport common faults.

2011–2016, hatchback, diesel, 150 HP.

The fault list covers: CUUB engine.

What you save stays on this device only. My saves

1 fault write-ups. Important. 3 recalls.

If you know the year, pick it. Faults for other years drop out of the list.

Before you buy

Known faults

1 important faults

Dual mass flywheel: diesel

expensive

The internal springs of the flywheel tire, and the two discs knock against each other. The signs are a rattling or knocking from the bellhousing at idle and when releasing the clutch pedal, and vibration through the floor. If the clutch slips without a burnt smell, that also points to the flywheel. It is worth replacing in time: a disintegrated flywheel can destroy the bellhousing too. At a clutch replacement the two go together anyway.

What to check

  • At idle, without touching the clutch pedal, listen for the rattle from the bellhousing, then press the pedal: if it stops, that is suspect
  • Watch for the characteristic clatter on starting and switching off
  • Put your foot on the floor at idle: a noticeable vibration indicates tired springs
2 more steps in the write-up

Checklist

Volkswagen Beetle 2.0 TDI 150hp BMT Sport

First what you would check on any car. Then the faults of this model.

Before you buy

Checklist

The printed sheet starts with what you would check on any car. What you tick stays on this device only.

On every car

Ask the owner

Faults of this model

vinkodex.com · Before you buy it, see what can go wrong.

Official recall3 recallsShow

The manufacturer fixes these for free at a franchised dealer. Ask with the VIN whether it was done.

Most recent: 16 December 2020

20V785000AIR BAGS:FRONTALAIR BAGS:FRONTAL16 December 2020 · NHTSA (USA)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2014 Volkswagen Beetle and Beetle Convertible vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Volkswagen will notify owners, and dealers will replace the driver frontal air bag, free of charge. The recall began March 19, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69BC.

The authority's notice

12V540000AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVEAIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE15 November 2012 · NHTSA (USA)

Volkswagen is recalling certain model year 2012-2013 Beetle vehicles, manufactured from February 2012, through August 2012, and equipped with leather sport seats. If the right front passenger seat gets wet, the occupant control module may not properly detect the presence of a child restraint installed in the seat.

Risk: If the control module does not detect a child seat installed, the airbag will not turn off. If the airbag does not turn off, in the event of a crash necessitating front airbag deployment, a child secured in the child seat may be at an increased risk for serious injury.

Remedy: Volkswagen will notify owners, and replace the control modules, free of charge. The recall is expected to begin during January 2013. Owners may contact Volkswagen at 1-800-822-8987.

The authority's notice

12V331000TIRESTIRES16 July 2012 · NHTSA (USA)

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2012 BEETLE VEHICLES. SOME VEHICLES MAY BE EQUIPPED WITH SUMMER TIRES THAT FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARDS 110 "TIRE SELECTION AND RIMS" AND 139 "NEW PNEUMATIC TIRES FOR LIGHT VEHICLES."

Risk: DUE TO AN ERROR AT THE FACTORY, THE AFFECTED VEHICLES WERE PRODUCED WITH SUMMER TIRES THAT ARE POSSIBLY NOT IN COMPLIANCE WITH FEDERAL MOTOR VEHICLE SAFETY STANDARDS 110 "TIRE SELECTION & RIMS" AND 139 "NEW PNEUMATIC TIRES FOR LIGHT VEHICLES." IN ADDITION, CUSTOMERS MAY BE UNAWARE THAT THEIR VEHICLE IS EQUIPPED WITH SUMMER PERFORMANCE TIRES. SUMMER TIRES HAVE DIFFERENT GRIP AND PERFORMANCE CHARACTERISTICS. THESE ISSUES MAY LEAD TO AN INCREASED RISK OF A CRASH.

Remedy: VOLKSWAGEN WILL NOTIFY OWNERS, AND REPLACE THE NONCOMPLIANT TIRES, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 12, 2012. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

The authority's notice

Engine and transmission

CUUB · 2.0 TDI BlueMotion Technology

110 kW (150 HP) · diesel

We built the code from the model and the gear count. The factory sheet does not state it.

Variant data

What is in this version

Factory data

Trim
BMT Sport
Body
hatchback
Fuel
diesel
Transmission
manual
Engine size
1968 cc
Power
110 kW (150 HP)
Drive
FWD
Production
2011–2016

Factory service interval

The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.

  • Air filter

    • 60,000 km or 4 years

  • Cabin (pollen) filter

    • 30,000 km or 2 years

  • Engine oil and oil filter

    • LongLife30,000 km or 2 years(valid only with LongLife-approved oil)
    • 15,000 km or 1 year

  • Brake fluid change

    • first: 3 years, then 2 years(first change at 3 years, then every two years)

  • Timing belt, 1.6 / 2.0 TDI (EA188/EA189/EA288)

    • 210,000 km(EA288, including the 1.6 TDI, with no time limit. 130,000 miles = 209,215 km. Parts maker repair specification, read by a human. The interval chart at https://www.rwcmotorsport.com/tech/tdi-maintenance.php gives the same figure independently.)

  • Coolant (antifreeze) change

    • first: 193,000 km or 10 years, then 97,000 km or 5 years(G13 / G12++: first change at 120,000 miles or 10 years, then every 60,000 miles or 5 years)

  • Fuel filter, diesel

    • 60,000 km or 2 years
All 5C versions

Information, not an expert opinion

We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.

  • A fault on the list does not mean the car you are looking at has it.
  • A fault missing from the list does not mean the model is fault-free. Write-ups are made model by model. Not all of them are done.
  • You decide whether to buy. This is no substitute for an inspection. That needs a workshop and a history check.
Details in the terms