vinkodex.

Mercedes-Benz G-Class G 400 d common faults.

2018–2024, SUV, diesel, 330 HP.

The fault list covers: OM656D29RSCR engine, MB7250 transmission.

What you save stays on this device only. My saves

2 fault write-ups. Both are important. 9 recalls.

If you know the year, pick it. Faults for other years drop out of the list.

Before you buy

Known faults

2 important faults

critical1

OM654 / OM656: vacuum controlled coolant pump leak, fire risk

critical

On the OM654 and OM656 diesels the maker started a recall over the vacuum controlled coolant pump (maker action code: 2090008). The fault: a leak can develop between the coolant and the vacuum circuit; if coolant reaches the electric switching valves, an electrochemical reaction can raise the temperature of the part, and a fire risk cannot be ruled out.

Show the rest

The fix: replacing the electric switching valve and a software update. The campaign started at the end of 2021; the affected group is the C-Class, E-Class and other OM654/OM656 models.

A recall on the model does not mean it was carried out on this car. Only the franchised dealer can tell you, by VIN.

What to check

  • Ask the franchised dealer by VIN: is action 2090008 OPEN or CLOSED
  • Check the coolant level and look around the vacuum system for leaks
  • Ask for the service sheet: a switching valve replacement plus a software update is part of the campaign
1 more steps in the write-up

expensive1

OM654 / OM656 diesel: roller finger follower wear and DPF driven oil dilution

expensive

The modern OM654 four cylinder diesel (and the modular OM656 six cylinder) carries two weaknesses on the used market that reinforce each other.

Show the rest

1) Roller finger followers (Rollenschlepphebel). According to the German technical press, on some cars the followers wear early at around 100,000 to 120,000 km. On 10 July 2018 the maker introduced a strengthened follower from engine number 80278367 (new part number A6540505701 in place of the old A6540501100). On early built cars the risk is higher. A faulty follower develops so much heat that the removed metal shows blue discolouration (Anlaufspur).

2) Oil dilution. The post injection needed to regenerate the particulate filter puts diesel fuel into the engine oil. With short urban use the engine does not get warm enough, the fuel does not evaporate, the oil thins out, and the follower and valvetrain are exactly what suffers most from poor lubrication.

The timing chain sits on the gearbox side: if it stretches, the replacement is labour intensive. There are few complaints of a broken chain, but on the early series about 5,000 cars were recalled for a weak chain, and the Tritan 15 coating was changed to Tritan 18.

between 80,000 and 160,000 km

What to check

  • Listen to the engine on a cold start: metallic ticking or rattling from the follower or the chain is suspect
  • Ask for the engine number: cars below 80278367 (before July 2018) are the old follower group
  • Check the service book: how often and with what oil (MB 229.52 is recommended) it was changed. Long intervals plus urban use is the worst pairing
2 more steps in the write-up

Checklist

Mercedes-Benz G-Class G 400 d

First what you would check on any car. Then the faults of this model.

Before you buy

Checklist

The printed sheet starts with what you would check on any car. What you tick stays on this device only.

On every car

Ask the owner

Faults of this model

vinkodex.com · Before you buy it, see what can go wrong.

Official recall9 recallsShow

The manufacturer fixes these for free at a franchised dealer. Ask with the VIN whether it was done.

Most recent: 17 February 2023

23V097000ELECTRICAL SYSTEM:WIRINGELECTRICAL SYSTEM:WIRING17 February 2023 · NHTSA (USA)

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2019-2021 G550 and AMG G63 vehicles. The front axle wiring harness may chafe against an oil cooler and become damaged, which can cause a loss of anti-lock brakes (ABS) and electronic stability control (ESC).

Risk: A loss of anti-lock brakes or electronic stability control can increase the risk of a crash.

Remedy: Dealers will inspect and either install a protective sleeve or replace the front axle wiring harness, as necessary, free of charge. Owner notification letters were mailed April 10, 2023. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2023030005.

The authority's notice

21V483000SEAT BELTS:REAR/OTHER:RETRACTORSEAT BELTS:REAR/OTHER:RETRACTOR25 June 2021 · NHTSA (USA)

Mercedes-Benz, LLC (MBUSA) is recalling certain 2021 G550, AMG G63, E350, E450, AMG CLS53, AMG E53, AMG GT43, AMG GT53, AMG GT63, 2021-2022 CLS450, and AMG E63 vehicles. The rear seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk: An unsecured child restraint system can increase the risk of injury during a crash.

Remedy: Dealers will inspect, and replace as necessary, the rear seat belt assemblies, free of charge. Owners notified of the voluntary recall campaign by an interim letter on August 13, 2021. A final letter was mailed on September 24, 2021. Owners may contact MBUSA customer service at 1-800-367-6372.

The authority's notice

A12/00045/22Safety recallFireno date · EU Safety Gate

The vacuum-controlled coolant pump may not be tightly sealed between the coolant and vacuum circuits. This may result in the coolant leaking into the vacuum circuit leading to an electrochemical reaction, increasing the risk of fire. The product does not comply with the requirements laid down in the Regulation on the approval and market surveillance of Motor Vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/00070/23Safety recallInjuriesno date · EU Safety Gate

Cracks may appear in the rear axle transmission housing which can lead to oil leaks on the road, increasing the risk of an accident for other traffic. The cracks can also cause the casing to break, which can result in power transmission loss to the rear axle and impaired steering. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/01006/21Safety recallInjuriesno date · EU Safety Gate

Depending on the tolerances of the latch and lock trap, the rear doors may not be fully closed, although they appear to be closed. As a result, certain driving manoeuvres and road conditions could cause the rear doors to open unexpectedly while driving, increasing the risk of accident. Additionally, if the child safety lock is activated on the rear doors and excessive force is used on the inner door handle to attempt to open them from inside the vehicle, the closing lever of the lock mechanism may become deformed and prevent the rear doors from being opened from the inside, increasing the risk of injury in the event of an accident.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/01436/22Safety recallInjuriesno date · EU Safety Gate

In some vehicles, the front cardan shaft can collide with the clamping body and damage it, which could lead to a sudden loss of vehicle propulsion, locking of the automatic transmission and wheels, increasing the risk of an accident. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/01558/23Safety recallInjuriesno date · EU Safety Gate

The oil supply to the drive shaft bearing in the rear axle differential may be inadequate, which could lead to that the car suddenly loses speed, creating a risk of an accident. Moreover, the rear wheels may lock, resulting in a loss of vehicle control and/or transmission oil may leak or vehicle parts may fall onto the road, endangering other road users. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/01765/23Safety recallInjuriesno date · EU Safety Gate

Due to improper screws in the door drive mechanism, the electric hydraulic interior swing door may open independently up to 30% while the vehicle is being driven and then close itself. This could increase the risk of injuries to the passengers. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/01779/23Safety recallInjuriesno date · EU Safety Gate

The monitor support near the middle door may break along the welded seams in the direction of travel below the interior ceiling as a result of vibrations. In the event of breakage, the support may fall down creating a risk of injury to passengers in the area of the door. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

Engine and transmission

OM656D29RSCR

210–243 kW (286–330 HP) · diesel

MB7250 · 9G-Tronic, longitudinal (Mercedes 725.0 / NAG3)

automatic · 9 speed

Torque limit700 Nm
MakerMercedes-Benz

We built the code from the model and the gear count. The factory sheet does not state it.

Variant data

What is in this version

Factory data

Trim
G 400 d
Body
SUV
Fuel
diesel
Transmission
automatic
Engine size
2925 cc
Power
243 kW (330 HP)
Drive
AWD
Production
2018–2024

Factory service interval

The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.

  • Air filter

    • 60,000 km or 4 years

  • Cabin (pollen) filter

    • 30,000 km or 2 years

  • Brake fluid change

    • first: 3 years, then 2 years(first change at 3 years, then every two years)

  • Fuel filter, diesel

    • 60,000 km or 2 years
All W463 versions

Information, not an expert opinion

We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.

  • A fault on the list does not mean the car you are looking at has it.
  • A fault missing from the list does not mean the model is fault-free. Write-ups are made model by model. Not all of them are done.
  • You decide whether to buy. This is no substitute for an inspection. That needs a workshop and a history check.
Details in the terms