vinkodex.

Mercedes-Benz GLK-Class GLK 200 CDI common faults.

2012–2015, SUV, diesel, 143 HP.

The fault list covers: OM651DE22LA engine, MB7229 transmission.

What you save stays on this device only. My saves

5 fault write-ups. All are important. 2 recalls.

If you know the year, pick it. Faults for other years drop out of the list.

Before you buy

Known faults

5 important faults

critical2

OM651: the chain tensioner seal leaks and oil drips onto the exhaust

critical

The chain tensioner seal starts to leak and engine oil can drip onto the exhaust system. On the hot exhaust the oil can ignite.

Show the rest

The manufacturer issued a recall for it, covering more than 100,000 cars built between February and November 2014. The repair is free under the campaign. The visible signs are oil traces at the back of the engine and a burnt smell.

What to check

  • Look at the back of the engine from underneath: oil traces point at the tensioner seal
  • Smell the engine bay when warm: burnt oil has a telling smell
  • Look at the top of the exhaust: baked-on oil leaves a mark
2 more steps in the write-up

OM651: the sealing ring of the chain tensioner leaks and the chain can loosen

critical

The sealing ring of the chain tensioner starts to let through, and engine oil escapes at the tensioner. The cause is insufficient manufacturing tolerance of the sealing rings. Beyond the loss of oil the chain tensioner can also loosen, and in an extreme case the timing chain comes free, which means engine damage. A separate phenomenon is that on the early OM651 engines a shortcoming of the tensioner let the chain stretch prematurely, which typically caused serious engine damage. The maker revised the tensioner several times, so this mainly affects the older units. The maker issued a recall, for more than 100,000 cars in Germany and for 2,869 cars and 2,579 vans in Austria. The range is the four-cylinder diesel units built between February and November 2014. The classes affected are A, B, C, E, S, V, CLA, GLA, GLK, SLK, CLS, ML, GL, Vito, Viano and Sprinter. It also affects older cars that received a replacement engine or chain tensioner from that period. The repair is replacing the sealing ring, free of charge under the campaign, and takes 1.5 to 2.5 hours of workshop time. The visible sign is an oil trace at the rear of the engine.

What to check

  • Ask whether the recall has been carried out, and ask for the workshop confirmation
  • Start the engine cold and listen for a clacking or rattling noise
  • Listen to the chain on lifting off and on load changes as well
2 more steps in the write-up

expensive3

OM651 2.1/2.2 diesel: Delphi piezo injectors and rear timing chain

expensive

The Mercedes OM651 common rail diesel has two faults that are independent of each other.

Show the rest

1) Delphi piezo injectors. According to the German technical press the fault affected the two more powerful versions (125 kW / 170 hp and 150 kW / 204 hp). The weaker versions got solenoid injectors and were not affected. The fault could show up as early as around 50,000 km: the engine drops into limp mode, power is limited, and the car can still be driven slowly. Because of supply shortages the maker at first replaced only the failed injector rather than all four, so some owners went back four times. Later they moved to replacing the full set. From spring 2011 every 220 CDI version got solenoid injectors; the 250 CDI kept piezo injectors throughout, in several revised versions.

2) Timing chain. The engine runs on gears plus a short simplex roller chain. Increased chain wear (typically caused by a faulty chain tensioner) shows up occasionally at higher mileage. The replacement is very labour intensive, because the chain sits on the rear of the engine, on the gearbox side. The labour is the bigger part of the bill.

In November 2014 the chain tensioner caused trouble again: it can release, and engine oil can leak. The maker recalled cars built between February and November 2014. If the car falls in that window, check that the campaign was carried out.

The water pump can leak too.

between 50,000 and 250,000 km

What to check

  • Check the power output first: the 125 kW (170 hp) and 150 kW (204 hp) versions are the piezo injector, higher risk group. The weaker ones got solenoid injectors
  • Ask whether the injectors were replaced, and how many: a partial replacement meant repeat workshop visits
  • Listen to the engine on a cold start: rough running, shaking, smoke; limp mode or limited power while driving
4 more steps in the write-up

7G-Tronic (722.9): mechatronics and conductor plate

expensive

In the Mercedes 7 speed 722.9 automatic (7G-Tronic / 7G-Tronic Plus) the mechatronics unit and the conductor plate (Leiterplatte) age over time: jerking on shifts, delayed engagement, a "Getriebe schützen" message, and fault codes on the gearbox electronics.

Show the rest

The repair is typically replacing the mechatronics unit or the conductor plate together with an oil change: not the whole gearbox. The complaint is most common on the longitudinal platforms from around 2005 to 2015 (C/E/ML and the early GLC).

The 9G-Tronic (725.0) is a different design; this applies only to the 7G.

between 100,000 and 220,000 km

What to check

  • Try it cold and warm: a delayed 1 to 2 or 2 to 3 shift is suspect
  • Watch for the gearbox warning or the "Getriebe schützen" message on the dash
  • Ask for a fault code read on the gearbox controller (not just the engine codes)
1 more steps in the write-up

OM651 diesel: contested defeat device, KBA authority recalls

expensive

The Stuttgart public prosecutor investigated the OM651 diesel on suspicion of an illegal defeat device (Abschalteinrichtung): the engine management returns better emission figures on the test bench than in real use. According to the German technical press the suspicion covered more than one million cars sold in Europe and the USA between 2008 and 2016.

Show the rest

For Germany the suspicion was confirmed in KBA recalls supervised by the authority:

  • KBA 8227: GLC 220d / GLC 250d, 06.2015 to 06.2018
  • KBA 8251, 8252, 8253, 8314: Vito 2.2 diesel, 09.2014 to 09.2016 (partly classed as M1 passenger cars, partly as N1 commercial vehicles)

The ADAC lists these on top: C 220d / C 250d and C 220 / C 250 BlueTEC (12.2013 to 05.2018), S 300 BlueTEC HYBRID / S 300 h (12.2013 to 09.2016), ML 250 BlueTEC (08.2011 to 06.2015), and possibly the GLE 250d. In October 2019 the KBA ordered a third recall as well.

A large share of the cars exported out of the German market come from exactly this group, and the paperwork does not show whether the software update was done. In most countries this alone does not take the car off the road, but it hurts the car's value and how easily you can sell it on.

After the update many owners report higher fuel consumption and worse drivability: you notice that while driving, not from the documents. And in March 2021 the Stuttgart regional court found deliberate, immoral conduct on the maker's part and awarded a C 220 buyer around 25,000 euro in damages (7 O 224/20).

What to check

  • Ask the franchised dealer, by VIN, whether the KBA recall (8227 / 8251 / 8252 / 8253 / 8314) applies to this car and whether it was carried out
  • On an imported car ask for the German service history: the software update is documented there
  • If it was carried out: watch the drivability on the test drive and ask about real fuel consumption, because the update can make both worse
2 more steps in the write-up

Checklist

Mercedes-Benz GLK-Class GLK 200 CDI

First what you would check on any car. Then the faults of this model.

Before you buy

Checklist

The printed sheet starts with what you would check on any car. What you tick stays on this device only.

On every car

Ask the owner

Faults of this model

vinkodex.com · Before you buy it, see what can go wrong.

Official recall2 recallsShow

The manufacturer fixes these for free at a franchised dealer. Ask with the VIN whether it was done.

Most recent: 9 January 2019

19V010000AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULEAIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE9 January 2019 · NHTSA (USA)

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2014 C250, C300 4Matic, C350, C63 AMG, E350 4Matic Coupe, E350 Cabrio, E350 Coupe, SLS AMG Cabrio, SLS AMG Coupe, 2014-2015 C250 Coupe, C350 4Matic Coupe, C350 Coupe, C63 AMG Coupe, GLK 350, GLK250 BlueTec 4Matic, GLK350 RWD, 2015-2017 E400 4Matic Coupe, E400 Cabrio, E400 Coupe, 2014-2017 E550 Cabrio, and 2014-2016 E550 Coupe vehicles sold, or ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP, and VI or "Zone A." Additionally, MBUSA is recalling certain 2012-2014 C250, E350 4Matic Coupe, SLS AMG Cabrio, 2012-2015 C250 Coupe, C350 4Matic Coupe, C350 Coupe, C63 AMG Coupe, 2011 C300, 2011-2014 C300 4Matic, C350, C63 AMG, E350 Cabrio, E350 Coupe, SLS AMG Coupe, 2015-2016 E400 4Matic Coupe, E400 Cabrio, E400 Coupe, 2011-2016 E550 Cabrio, E550 Coupe, 2011-2015 GLK350 4Matic, GLK350 RWD, and 2013-2015 GLK250 BlueTec 4Matic vehicles ever registered in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." MBUSA is also recalling certain 2012-2014 C250, E350 4Matic Coupe, SLS AMG Cabrio 2012-2015 C250 Coupe, C350 4Matic Coupe, C350 Coupe, C63 AMG Coupe, 2010-2011 C300, 2010-2014 C300 4Matic, C350, C63 AMG, E350 Coupe, 2011-2014 E350 Cabrio, SLS AMG Coupe, 2015-2016 E400 4Matic Coupe, E400 Cabrio, E400 Coupe, 2016-2017 E550 Cabrio, 2010-2016 E550 Coupe, 2010-2015 GLK350 4Matic, GLK350 RWD, and 2013-2015 GLK250 BlueTec 4Matic vehicles ever registered in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MO, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI and WY or "Zone C." These vehicles are equipped with air bag inflators assembled as part of the passenger frontal air bag modules that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Risk: An inflator explosion may result in sharp metal fragments striking the passenger or other occupants resulting in serious injury or death.

Remedy: MBUSA will notify owners, and dealers will replace the passenger frontal air bag module, free of charge. The recall began March 29, 2019. Owners may contact MBUSA customer service at 1-800-367-6372.

The authority's notice

17V627000AIR BAGS:FRONTALAIR BAGS:FRONTAL6 October 2017 · NHTSA (USA)

Mercedes-Benz USA, LLC. (MBUSA) is recalling these vehicles: 2014-2018 CLA250, CLA250 4Matic, CLA45 AMG 4Matic, 2015-2018 GLA250, GLA250 4Matic, GLA45 AMG 4Matic, C300 4Matic, C63S AMG, 2012-2014 C250, C350, C300 4Matic, E550 4Matic, 2013-2014 C63 AMG, 2012-2015 C250 Coupe, C350 Coupe, C63 AMG Coupe, 2013-2015 C350 4Matic Coupe, GLK250 4Matic BlueTec, GLK350, GLK350 4Matic, 2016-2017 C350e, C43 AMG, 2015 C400 4Matic, 2016-2018 C63 AMG, GLC300, GLC300 4Matic, 2017-2018 C300 Coupe, C300 4Matic Coupe, C43 AMG, C63 AMG Coupe, C63S AMG Coupe, C300 Cabriolet, C300 4Matic Cabriolet, C43 AMG Cabriolet, C63 AMG Cabriolet, C63S AMG Cabriolet, GLC300 4Matic Coupe, GLC43 AMG, GLC43 AMG Coupe, 2014 E350 Coupe, E350 4Matic Coupe, E350 Cabriolet, E400 Hybrid, 2015-2017 E400 Coupe, E400 4Matic Coupe, E400 Cabriolet, 2014-2017 E550 Coupe, E550 Cabriolet, B250e, 2014-2016 E250 BlueTec, E63 AMG 4Matic Wagon, 2012-2013 E350 BlueTec, 2012-2016 E350, E350 4Matic, 2015-2016 E400, E400 4Matic, 2012 E63 AMG, 2014-2015 E250 4Matic BlueTec, 2013-2016 E350 Wagon, 2017 GLC300d 4Matic, and 2018 GLC350e 4Matic. The driver's air bag may unexpectedly deploy due to insufficient grounding of the steering components if an electrostatic discharge occurs and the air bag clockspring is broken.

Risk: If the driver air bag inadvertently deploys, it can increase the risk of injury and a crash.

Remedy: MBUSA will notify owners, and dealers will add sufficient grounding to the steering components, free of charge. The recall began in December 6, 2017. Owners may contact MBUSA customer service at 1-877-496-3691.

The authority's notice

Engine and transmission

OM651DE22LA · Viano 2.0 CDI BlueEFFICIENCY (4MATIC)

100–150 kW (136–204 HP) · diesel

MB7229 · 7G-Tronic / 7G-Tronic Plus, longitudinal (Mercedes 722.9 / NAG2)

automatic · 7 speed

Torque limit700 Nm
MakerMercedes-Benz

We built the code from the model and the gear count. The factory sheet does not state it.

Variant data

What is in this version

Factory data

Trim
GLK 200 CDI
Body
SUV
Fuel
diesel
Transmission
automatic
Engine size
2143 cc
Power
105 kW (143 HP)
Drive
RWD
Production
2012–2015

Factory service interval

The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.

  • Air filter

    • 60,000 km or 4 years

  • Cabin (pollen) filter

    • 30,000 km or 2 years

  • Brake fluid change

    • first: 3 years, then 2 years(first change at 3 years, then every two years)

  • Fuel filter, diesel

    • 60,000 km or 2 years
All X204 versions

Information, not an expert opinion

We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.

  • A fault on the list does not mean the car you are looking at has it.
  • A fault missing from the list does not mean the model is fault-free. Write-ups are made model by model. Not all of them are done.
  • You decide whether to buy. This is no substitute for an inspection. That needs a workshop and a history check.
Details in the terms