vinkodex.

Mercedes-Benz GLK-Class GLK 350 CDI 4Matic Ambition common faults.

2012–2015, SUV, diesel, 265 HP.

The fault list covers: OM642DELS30LA engine, MB7229 transmission.

What you save stays on this device only. My saves

4 fault write-ups. All are important. 3 recalls.

If you know the year, pick it. Faults for other years drop out of the list.

Before you buy

Known faults

4 important faults

critical1

OM642 V6 diesel: the swirl flap and its plastic linkage break

critical

The swirl flaps sit in the intake of both cylinder banks, and a central electric actuator moves them through a linkage. Soot builds up on the linkage and on the flaps, the flap starts to bind, and in the end the plastic breaks. This is the most frequent single failure on this engine, and the broken pieces can get into the engine, which can lead to engine damage. The symptoms are the engine warning light, rough running and a lack of power, with the code P2004 or P2005 in the fault memory. The condition of the flaps can be seen with an endoscope through the intake, without dismantling. It is worth looking above 150,000 km, especially on the W164 ML320 and ML350 CDI. An aluminium repair kit is available for it, which lasts longer than the factory part.

above 100,000 km

What to check

  • Read the fault memory and look for the P2004 and P2005 codes
  • Ask whether the flaps have been inspected with an endoscope, because they are visible without dismantling
  • At low revs watch for a lack of power and rough running
2 more steps in the write-up

expensive3

7G-Tronic (722.9): mechatronics and conductor plate

expensive

In the Mercedes 7 speed 722.9 automatic (7G-Tronic / 7G-Tronic Plus) the mechatronics unit and the conductor plate (Leiterplatte) age over time: jerking on shifts, delayed engagement, a "Getriebe schützen" message, and fault codes on the gearbox electronics.

Show the rest

The repair is typically replacing the mechatronics unit or the conductor plate together with an oil change: not the whole gearbox. The complaint is most common on the longitudinal platforms from around 2005 to 2015 (C/E/ML and the early GLC).

The 9G-Tronic (725.0) is a different design; this applies only to the 7G.

between 100,000 and 220,000 km

What to check

  • Try it cold and warm: a delayed 1 to 2 or 2 to 3 shift is suspect
  • Watch for the gearbox warning or the "Getriebe schützen" message on the dash
  • Ask for a fault code read on the gearbox controller (not just the engine codes)
1 more steps in the write-up

OM642 V6 diesel: leaking oil cooler seals in the engine valley

expensive

The oil cooler sits in the V between the cylinder banks, and its seal becomes porous over the years. The leak is characteristic: there is no visible trace on the outer sides of the engine, because the oil collects in the V under the intake and drips down from there. A smaller oil puddle can therefore appear under the car, while the place of the leak cannot be found from outside. As the fault gets worse, oil can also get into the coolant, and that shows up as oily streaks in the expansion tank. It gives no fault code. The repair is expensive because the cooler can only be reached after removing the intake and the swirl flap actuator. In a specialist workshop it can run up to 2,000 euro. The fault comes up above 120,000 km. One thing is worth asking even after the repair. If the V is not cleaned out thoroughly, the remains of the old seal and the soot get into the oil circuit, and there they can ruin the bearings and the oil passages as well.

above 120,000 kmup to 2,000 EUR

What to check

  • Look at the expansion tank: an oily streak means oil in the coolant
  • Look for an oil puddle under the car, but do not look for the leak on the side of the engine
  • Shine a light under the intake, between the cylinder banks, where the oil collects
2 more steps in the write-up

OM642 V6 diesel: the injector shaft soots up and it starts hard when cold

expensive

Combustion gases escape past the shaft of the Bosch piezo injector, and soot builds up around the shaft. The symptoms are a hard, rough cold start and a rough idle. The engine has six injectors, so finding the faulty one is more work as well. The quantity correction values of the control unit have to be read per injector, and this is worth doing before anyone replaces all of them. A cleaning additive and better quality fuel help to prevent the sooting. The fault comes up above 120,000 km. The high-pressure system of the same engine (Bosch CP3) can also give starting trouble and a lack of power at high mileage, so the diagnosis separates the two.

above 120,000 km

What to check

  • Start the engine cold and watch whether it starts hard or roughly
  • At idle watch for rough running
  • Ask for the quantity correction to be read per injector, not for a general fault code list
2 more steps in the write-up

Checklist

Mercedes-Benz GLK-Class GLK 350 CDI 4Matic Ambition

First what you would check on any car. Then the faults of this model.

Before you buy

Checklist

The printed sheet starts with what you would check on any car. What you tick stays on this device only.

On every car

Ask the owner

Faults of this model

vinkodex.com · Before you buy it, see what can go wrong.

Official recall3 recallsShow

The manufacturer fixes these for free at a franchised dealer. Ask with the VIN whether it was done.

Most recent: 9 January 2019

19V010000AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULEAIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE9 January 2019 · NHTSA (USA)

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2014 C250, C300 4Matic, C350, C63 AMG, E350 4Matic Coupe, E350 Cabrio, E350 Coupe, SLS AMG Cabrio, SLS AMG Coupe, 2014-2015 C250 Coupe, C350 4Matic Coupe, C350 Coupe, C63 AMG Coupe, GLK 350, GLK250 BlueTec 4Matic, GLK350 RWD, 2015-2017 E400 4Matic Coupe, E400 Cabrio, E400 Coupe, 2014-2017 E550 Cabrio, and 2014-2016 E550 Coupe vehicles sold, or ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP, and VI or "Zone A." Additionally, MBUSA is recalling certain 2012-2014 C250, E350 4Matic Coupe, SLS AMG Cabrio, 2012-2015 C250 Coupe, C350 4Matic Coupe, C350 Coupe, C63 AMG Coupe, 2011 C300, 2011-2014 C300 4Matic, C350, C63 AMG, E350 Cabrio, E350 Coupe, SLS AMG Coupe, 2015-2016 E400 4Matic Coupe, E400 Cabrio, E400 Coupe, 2011-2016 E550 Cabrio, E550 Coupe, 2011-2015 GLK350 4Matic, GLK350 RWD, and 2013-2015 GLK250 BlueTec 4Matic vehicles ever registered in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." MBUSA is also recalling certain 2012-2014 C250, E350 4Matic Coupe, SLS AMG Cabrio 2012-2015 C250 Coupe, C350 4Matic Coupe, C350 Coupe, C63 AMG Coupe, 2010-2011 C300, 2010-2014 C300 4Matic, C350, C63 AMG, E350 Coupe, 2011-2014 E350 Cabrio, SLS AMG Coupe, 2015-2016 E400 4Matic Coupe, E400 Cabrio, E400 Coupe, 2016-2017 E550 Cabrio, 2010-2016 E550 Coupe, 2010-2015 GLK350 4Matic, GLK350 RWD, and 2013-2015 GLK250 BlueTec 4Matic vehicles ever registered in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MO, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI and WY or "Zone C." These vehicles are equipped with air bag inflators assembled as part of the passenger frontal air bag modules that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Risk: An inflator explosion may result in sharp metal fragments striking the passenger or other occupants resulting in serious injury or death.

Remedy: MBUSA will notify owners, and dealers will replace the passenger frontal air bag module, free of charge. The recall began March 29, 2019. Owners may contact MBUSA customer service at 1-800-367-6372.

The authority's notice

17V627000AIR BAGS:FRONTALAIR BAGS:FRONTAL6 October 2017 · NHTSA (USA)

Mercedes-Benz USA, LLC. (MBUSA) is recalling these vehicles: 2014-2018 CLA250, CLA250 4Matic, CLA45 AMG 4Matic, 2015-2018 GLA250, GLA250 4Matic, GLA45 AMG 4Matic, C300 4Matic, C63S AMG, 2012-2014 C250, C350, C300 4Matic, E550 4Matic, 2013-2014 C63 AMG, 2012-2015 C250 Coupe, C350 Coupe, C63 AMG Coupe, 2013-2015 C350 4Matic Coupe, GLK250 4Matic BlueTec, GLK350, GLK350 4Matic, 2016-2017 C350e, C43 AMG, 2015 C400 4Matic, 2016-2018 C63 AMG, GLC300, GLC300 4Matic, 2017-2018 C300 Coupe, C300 4Matic Coupe, C43 AMG, C63 AMG Coupe, C63S AMG Coupe, C300 Cabriolet, C300 4Matic Cabriolet, C43 AMG Cabriolet, C63 AMG Cabriolet, C63S AMG Cabriolet, GLC300 4Matic Coupe, GLC43 AMG, GLC43 AMG Coupe, 2014 E350 Coupe, E350 4Matic Coupe, E350 Cabriolet, E400 Hybrid, 2015-2017 E400 Coupe, E400 4Matic Coupe, E400 Cabriolet, 2014-2017 E550 Coupe, E550 Cabriolet, B250e, 2014-2016 E250 BlueTec, E63 AMG 4Matic Wagon, 2012-2013 E350 BlueTec, 2012-2016 E350, E350 4Matic, 2015-2016 E400, E400 4Matic, 2012 E63 AMG, 2014-2015 E250 4Matic BlueTec, 2013-2016 E350 Wagon, 2017 GLC300d 4Matic, and 2018 GLC350e 4Matic. The driver's air bag may unexpectedly deploy due to insufficient grounding of the steering components if an electrostatic discharge occurs and the air bag clockspring is broken.

Risk: If the driver air bag inadvertently deploys, it can increase the risk of injury and a crash.

Remedy: MBUSA will notify owners, and dealers will add sufficient grounding to the steering components, free of charge. The recall began in December 6, 2017. Owners may contact MBUSA customer service at 1-877-496-3691.

The authority's notice

A12/0561/17Safety recallInjuriesno date · EU Safety Gate

The steering coupling might not have been screwed to the correct torque specification. As a consequence, the steering coupling can become detached from the steering wheel axle and it would become impossible to steer the vehicle.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

Engine and transmission

OM642DELS30LA

195 kW (265 HP) · diesel

MB7229 · 7G-Tronic / 7G-Tronic Plus, longitudinal (Mercedes 722.9 / NAG2)

automatic · 7 speed

Torque limit700 Nm
MakerMercedes-Benz

We built the code from the model and the gear count. The factory sheet does not state it.

Variant data

What is in this version

Factory data

Trim
GLK 350 CDI 4Matic Ambition
Body
SUV
Fuel
diesel
Transmission
automatic
Engine size
2987 cc
Power
195 kW (265 HP)
Drive
AWD
Production
2012–2015

Factory service interval

The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.

  • Air filter

    • 60,000 km or 4 years

  • Cabin (pollen) filter

    • 30,000 km or 2 years

  • Brake fluid change

    • first: 3 years, then 2 years(first change at 3 years, then every two years)

  • Fuel filter, diesel

    • 60,000 km or 2 years
All X204 versions

Information, not an expert opinion

We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.

  • A fault on the list does not mean the car you are looking at has it.
  • A fault missing from the list does not mean the model is fault-free. Write-ups are made model by model. Not all of them are done.
  • You decide whether to buy. This is no substitute for an inspection. That needs a workshop and a history check.
Details in the terms