vinkodex.

SEAT Ibiza 1.2 12V Selection common faults.

2002–2006, hatchback, petrol, 64 HP.

The fault list covers: AZQ, BME engine, MQ150 transmission.

What you save stays on this device only. My saves

1 fault write-ups. Important. No recall on the list.

If you know the year, pick it. Faults for other years drop out of the list.

Before you buy

Known faults

1 important faults

1.2 HTP (3 cylinder): the timing chain stretches

critical

The valvetrain of the three cylinder 1.2 runs on a chain instead of a belt. Both the chain and the tensioner are undersized for this engine. The chain starts stretching as early as 60,000 to 80,000 km, and the tensioner loses its pressure. The sign is a rattling noise audible for a few seconds on a cold start. The earliest BME has the weakest tensioner, and the BZG is structurally the same. If the chain jumps, the engine is badly damaged inside, and the repair is typically an engine rebuild. A low oil level speeds the wear up enormously: the tensioner is driven by oil pressure. That is why the oil level has to be checked every 1,000 km on this engine.

What to check

  • Start it cold: the rattling noise is audible in the first seconds and no longer when warm
  • Pull the dipstick: a low level is a risk on its own on this engine
  • Ask whether the chain and the tensioner were replaced, and ask for the invoice
2 more steps in the write-up

Checklist

SEAT Ibiza 1.2 12V Selection

First what you would check on any car. Then the faults of this model.

Before you buy

Checklist

The printed sheet starts with what you would check on any car. What you tick stays on this device only.

On every car

Ask the owner

Faults of this model

vinkodex.com · Before you buy it, see what can go wrong.

Engine and transmission

2 engines · 1 transmissions

AZQ · 1.2

47 kW (64 HP) · petrol

MQ150 · 5-speed manual, small car

manual · 5 speed

Torque limit150 Nm
MakerVolkswagen

We built the code from the model and the gear count. The factory sheet does not state it. More than one engine code is possible. The fault list shows the faults of each.

Variant data

What is in this version

Factory data

Trim
12V Selection
Body
hatchback
Fuel
petrol
Transmission
manual
Engine size
1198 cc
Power
47 kW (64 HP)
Drive
FWD
Production
2002–2006

Factory service interval

The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.

  • Air filter

    • 60,000 km or 4 years

  • Cabin (pollen) filter

    • 30,000 km or 2 years

  • Engine oil and oil filter

    • LongLife30,000 km or 2 years(valid only with LongLife-approved oil)
    • 15,000 km or 1 year

  • Brake fluid change

    • first: 3 years, then 2 years(first change at 3 years, then every two years)

  • Coolant (antifreeze) change

    • first: 193,000 km or 10 years, then 97,000 km or 5 years(G13 / G12++: first change at 120,000 miles or 10 years, then every 60,000 miles or 5 years)

  • Spark plugs, petrol

    • 60,000 km or 6 years
All III versions

Information, not an expert opinion

We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.

  • A fault on the list does not mean the car you are looking at has it.
  • A fault missing from the list does not mean the model is fault-free. Write-ups are made model by model. Not all of them are done.
  • You decide whether to buy. This is no substitute for an inspection. That needs a workshop and a history check.
Details in the terms