vinkodex.

Volkswagen Passat 1.6 Trendline common faults.

2005–2010, saloon, petrol, 102 HP.

The fault list covers: BSF, BSE, CCSA engine, MQ200, MQ250, MQ350 transmission.

What you save stays on this device only. My saves

5 fault write-ups. 2 important. 5 recalls.

If you know the year, pick it. Faults for other years drop out of the list.

Before you buy

Known faults

2 important faults

expensive2

MQ200 / MQ250 manual gearbox: differential bearing and synchros

expensive

The light, magnesium cased MQ200 and the MQ250, sized for higher torque, are the most widespread manual gearboxes in the transverse engine VAG models. Both have the same two weak points, and both depend on use.

Show the rest

The first is the differential bearing: as it wears you first get a droning, then a whine from the thrust bearings of the output shaft. Left alone, the planetary shaft can fail and in extreme cases punch through the gearbox casing: from then on it is not a repair but a replacement.

The second is the synchros: they can start crunching at around 50,000 km with aggressive driving. This type does not like dumping the clutch or slipping it, and on a used car that is exactly what you have to listen for.

above 50,000 km

What to check

  • On the test drive with the window down, listen to the gearbox both off and on the throttle: droning or whining is suspect
  • Shift up and down quickly, especially into 2nd and 3rd: crunching means synchro wear
  • Try engaging 1st and reverse when cold: resistance here means wear
2 more steps in the write-up

B6 / B7: electric parking brake seizing

expensive

The servo motor of the electric parking brake seizes: the brake does not release, or does not apply properly. The repair is replacing the motor or the switch, and the rear caliper can be affected too. On a used car it is a separate warning sign if the seller blames only the switch.

What to check

  • Apply and release the electric parking brake five or six times in a row
  • Watch whether it releases evenly and without noise on both sides
  • Try it on a slope: does it really hold the car
1 more steps in the write-up

comfort3

B6 / B7: electrical fault in the door lock module

comfort

The contacts of the lock module cannot take the current draw of the lock motor, so over time they burn through and their resistance rises. At first the door only sometimes fails to open or lock centrally, later not at all. The alarm often reports it too: the car sees a closed door as open. Typical fault codes are 67074 (central locking motors, electrical fault) and 67330.

What to check

  • Lock and unlock centrally ten times in a row, watching all four doors
  • Check on the dash whether it reports an open door while closed
  • Try it when cold too: at first the fault only appears at low temperature
2 more steps in the write-up

Coolant temperature sensor (G62) failure

comfort

The G62 sensor tells the engine control unit how hot the coolant is. If it is faulty, the control unit thinks a warm engine is cold, and runs it rich: hard warm or cold starting, a rough idle, markedly increased fuel consumption, and a dash temperature gauge that jumps around or never reaches its usual reading. The part is cheap and can be replaced in half an hour: the trouble is that many people do not recognise it and replace an injector or a lambda sensor instead. If the fault persists, the rich mixture can destroy the catalytic converter too.

What to check

  • Warm it up and watch the dash temperature gauge: the needle should sit steadily at the middle reading, not jump around
  • Watch a cold start, then a warm start after twenty minutes standing
  • With a code reader look for the 17664 / P1256 code in the engine control unit
2 more steps in the write-up

Secondary air system: pump and combination valve (P0411)

comfort

From the late nineties to around 2006, petrol engines used a secondary air pump to blow fresh air into the exhaust on a cold start, so the catalytic converter reaches operating temperature faster. The impeller of the pump rusts or its bearing seizes, soot clogs the combination valve (N112), and the rubber hoses crack. The control unit then stores the `P0411` code. It barely affects driving, but the engine warning light is on, and the emissions test can fail because of it, and the roadworthiness test with it.

What to check

  • After a cold start watch for 30 to 60 seconds: can you hear the pump droning from the engine bay
  • Check whether the engine warning light is on, and have it read out: P0411 (VAG code 16795) points to this system
  • Ask when the last emissions test was, and whether it passed first time
2 more steps in the write-up

Checklist

Volkswagen Passat 1.6 Trendline

First what you would check on any car. Then the faults of this model.

Before you buy

Checklist

The printed sheet starts with what you would check on any car. What you tick stays on this device only.

On every car

Ask the owner

Faults of this model

vinkodex.com · Before you buy it, see what can go wrong.

Official recall5 recallsShow

The manufacturer fixes these for free at a franchised dealer. Ask with the VIN whether it was done.

Most recent: 7 April 2008

08V156000FUEL SYSTEM, GASOLINE:DELIVERYFUEL SYSTEM, GASOLINE:DELIVERY7 April 2008 · NHTSA (USA)

VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.

Risk: A HEAT SHIELD THAT MAY CONTACT THE EXHAUST SYSTEM CAN RESULT IN A VEHICLE FIRE. IN ADDITION, A FUEL LEAK FROM A FUEL LINE OR FUEL TANK VENTILATION VALVE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN LEAD TO A VEHICLE FIRE.

Remedy: DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

The authority's notice

07V063000EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCHEXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH20 February 2007 · NHTSA (USA)

ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.

Risk: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.

Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.

The authority's notice

04V586000FUEL SYSTEM, DIESELFUEL SYSTEM, DIESEL15 December 2004 · NHTSA (USA)

ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP.

Risk: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE.

Remedy: DEALERS WILL REPLACE THE DIESEL PUMP. THE RECALL BEGAN ON FEBRUARY 8, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.

The authority's notice

A12/01485/22Safety recallInjuriesno date · EU Safety Gate

The airbag propellant may deteriorate over time. In the event of an accident this can lead to the release of fragments of the front airbag from the generator housing, increasing the risk of injury. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/01892/20Safety recallInjuriesno date · EU Safety Gate

The vehicles affected may have been fitted with Takata gas generators which could allow the ingress of moisture and thus result in the degradation of the propellant. If the airbag deploys, this could cause the gas generator to burst, causing metal parts to enter the vehicle's interior, causing injuries to the occupants of the vehicle.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

Engine and transmission

3 engines · 3 transmissions

BSF · 1.6

75 kW (102 HP) · petrol

MQ200 · 5- or 6-speed manual

manual · 5–6 speed

Torque limit200 Nm
MakerVolkswagen

We built the code from the model and the gear count. The factory sheet does not state it. More than one engine code is possible. The fault list shows the faults of each. More than one transmission is possible. The gear count does not tell them apart. The code is on the side of the transmission.

Variant data

What is in this version

Factory data

Trim
Trendline
Body
saloon
Fuel
petrol
Transmission
manual
Engine size
1595 cc
Power
75 kW (102 HP)
Drive
FWD
Production
2005–2010

Factory service interval

The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.

  • Air filter

    • 60,000 km or 4 years

  • Cabin (pollen) filter

    • 30,000 km or 2 years

  • Engine oil and oil filter

    • LongLife30,000 km or 2 years(valid only with LongLife-approved oil)
    • 15,000 km or 1 year

  • Brake fluid change

    • first: 3 years, then 2 years(first change at 3 years, then every two years)

  • Coolant (antifreeze) change

    • first: 193,000 km or 10 years, then 97,000 km or 5 years(G13 / G12++: first change at 120,000 miles or 10 years, then every 60,000 miles or 5 years)

  • Spark plugs, petrol

    • 60,000 km or 6 years
All B6 versions

Information, not an expert opinion

We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.

  • A fault on the list does not mean the car you are looking at has it.
  • A fault missing from the list does not mean the model is fault-free. Write-ups are made model by model. Not all of them are done.
  • You decide whether to buy. This is no substitute for an inspection. That needs a workshop and a history check.
Details in the terms