vinkodex.

Audi Q3 2.0 TDI 150hp quattro sport common faults.

2015–2018, SUV, diesel, 150 HP.

The fault list covers: CUVC engine, DQ500 transmission.

What you save stays on this device only. My saves

4 fault write-ups. 2 important. 4 recalls.

If you know the year, pick it. Faults for other years drop out of the list.

Before you buy

Known faults

2 important faults

expensive2

DQ500 (7 speed wet clutch DSG): mechatronics and differential

expensive

The seven speed, wet clutch DQ500 is the DSG of the high torque models (Transporter, Arteon, Tiguan). On a heavy vehicle, on the T5 vans, the splined joint of the differential can shear. Clutch debris blocks the valves of the mechatronics unit, and it jerks on shifts. The pressure sensors fail at around 100,000 to 150,000 km, and then either the even or the odd gears drop out. The control board fails from overheating next to a clogged heat exchanger. It is not repairable, only replaceable.

What to check

  • On the test drive watch for jerking between 1st and 2nd and 2nd and 3rd, cold and warm
  • Pull away gently from standstill: shuddering indicates clutch wear
  • If a whole group of gears (even or odd) is missing, that is a pressure sensor fault
3 more steps in the write-up

Dual mass flywheel: diesel

expensive

The internal springs of the flywheel tire, and the two discs knock against each other. The signs are a rattling or knocking from the bellhousing at idle and when releasing the clutch pedal, and vibration through the floor. If the clutch slips without a burnt smell, that also points to the flywheel. It is worth replacing in time: a disintegrated flywheel can destroy the bellhousing too. At a clutch replacement the two go together anyway.

What to check

  • At idle, without touching the clutch pedal, listen for the rattle from the bellhousing, then press the pedal: if it stops, that is suspect
  • Watch for the characteristic clatter on starting and switching off
  • Put your foot on the floor at idle: a noticeable vibration indicates tired springs
2 more steps in the write-up

comfort1

Infotainment that freezes, false warnings

comfort

The most common complaint on the Q3 is the infotainment system: the touchscreen does not respond, dash warnings flicker, the system freezes, or a sensor is faulty. One survey found a fault of this kind on 44 per cent of Q3 cars, and half of the repairs spent more than a week in the workshop. A software update fixes many cases and the update is free, so before you buy, ask whether the latest version is installed.

What to check

  • Leave the system running for the whole test drive and watch for freezing
  • Try the parking sensors and the driver assistance systems
  • Restart the car several times: a fault after a cold start is characteristic
2 more steps in the write-up

cheap repair1

DSG selector lever: failure of the P position switch

cheap repair

The dash shows "Error: Workshop! Only leave vehicle in position P" with an audible warning. The message appears in whatever language the car is set to, for example "Fehler: Werkstatt! Fahrzeug nur in Stellung P verlassen" in German.

Show the rest

The message points at the gearbox, but the fault is not there. A tiny switch sits in the module under the selector lever and signals that the lever is in park (P). Its contact wears and can also burn. That makes the signal unreliable, and the car warns you. The fault codes appear as 617752, P173400 or B116229.

At first it is intermittent. Sometimes the message comes up, sometimes not, so a short test drive easily misses it. Later it becomes permanent, and the gearbox can drop into limp mode.

This fault looks more expensive than it is. The maker released a separate retrofit switch kit for it (5Q0713128A for the black module, 3Q0713128 for the white one), which can be fitted in half an hour. The kit costs 70 to 100 pounds. At a franchised dealer, however, the whole selector lever module sometimes gets replaced, which costs 626 to 1,000 pounds there. So the difference between the two routes is roughly tenfold.

The affected group is post 2013 MQB platform Volkswagen, Audi, Seat and Skoda cars with a DSG gearbox. The switch is in these gearboxes, because that is what these cars have in common. The part itself is not part of the gearbox but of the module under the lever.

What to check

  • Watch the dash after starting: the message is intermittent and can be missed on a short loop
  • Move the lever from P to D and back several times, then get out and lock the car
  • Ask whether the selector lever switch has been replaced already, and ask for the invoice
2 more steps in the write-up

Checklist

Audi Q3 2.0 TDI 150hp quattro sport

First what you would check on any car. Then the faults of this model.

Before you buy

Checklist

The printed sheet starts with what you would check on any car. What you tick stays on this device only.

On every car

Ask the owner

Faults of this model

vinkodex.com · Before you buy it, see what can go wrong.

Official recall4 recallsShow

The manufacturer fixes these for free at a franchised dealer. Ask with the VIN whether it was done.

Most recent: 26 June 2017

17V400000EXTERIOR LIGHTING:BRAKE LIGHTSEXTERIOR LIGHTING:BRAKE LIGHTS26 June 2017 · NHTSA (USA)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2016-2017 Audi Q3 vehicles. If the parking brake is used during emergency braking, the brake lights on the vehicle will not activate. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk: A vehicle approaching from behind may not have any warning that the vehicle is stopping, increasing the risk of a crash.

Remedy: Audi will notify owners, and dealers will update the vehicle software, free of charge. The recall began July 31, 2017. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 45G6.

The authority's notice

A12/0204/18Safety recallInjuriesno date · EU Safety Gate

A welded joint in the gas generator of the front passenger airbag may be faulty. This means that, in the event of an accident, the airbag may not deploy properly.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/1252/19Safety recallInjuriesno date · EU Safety Gate

The function control device of the Body Control Module (BCM) may be incorrectly configured. This may cause a malfunction of the front light-emitting diode (LED) turn signal lights (blinkers) without the required warning indicator (acoustic/optical), increasing the risk of an accident.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/1639/17Safety recallInjuriesno date · EU Safety Gate

When emergency braking is actuated using the EPB (electro-mechanical parking brake), the braking lights are not activated. Following traffic is not informed of the emergency braking operation and the resulting deceleration of the vehicle which could lead to an accident.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

Engine and transmission

CUVC · 2.0 TDI

110 kW (150 HP) · diesel

DQ500 · 7-speed DSG, wet clutch, high-torque

DSG · 7 speed

Clutchwet
Torque limit600 Nm
MakerVolkswagen

We built the code from the model and the gear count. The factory sheet does not state it.

Variant data

What is in this version

Factory data

Trim
quattro sport
Body
SUV
Fuel
diesel
Transmission
automatic
Engine size
1968 cc
Power
110 kW (150 HP)
Drive
AWD
Production
2015–2018

Factory service interval

The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.

  • Air filter

    • 60,000 km or 4 years

  • Cabin (pollen) filter

    • 30,000 km or 2 years

  • Engine oil and oil filter

    • LongLife30,000 km or 2 years(valid only with LongLife-approved oil)
    • 15,000 km or 1 year

  • Brake fluid change

    • first: 3 years, then 2 years(first change at 3 years, then every two years)

  • DSG oil change, WET clutch gearbox

    • 60,000 km or 4 years

  • Timing belt, 1.6 / 2.0 TDI (EA188/EA189/EA288)

    • 210,000 km(EA288, including the 1.6 TDI, with no time limit. 130,000 miles = 209,215 km. Parts maker repair specification, read by a human. The interval chart at https://www.rwcmotorsport.com/tech/tdi-maintenance.php gives the same figure independently.)

  • Coolant (antifreeze) change

    • first: 193,000 km or 10 years, then 97,000 km or 5 years(G13 / G12++: first change at 120,000 miles or 10 years, then every 60,000 miles or 5 years)

  • Fuel filter, diesel

    • 60,000 km or 2 years
All 8U versions

Information, not an expert opinion

We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.

  • A fault on the list does not mean the car you are looking at has it.
  • A fault missing from the list does not mean the model is fault-free. Write-ups are made model by model. Not all of them are done.
  • You decide whether to buy. This is no substitute for an inspection. That needs a workshop and a history check.
Details in the terms