vinkodex.

Volkswagen Touran 1.6 TDI 105hp BMT Comfortline common faults.

2010–2015, MPV, diesel, 105 HP.

The fault list covers: CAYC engine, DQ200 transmission.

What you save stays on this device only. My saves

9 fault write-ups. 8 important. 4 recalls.

If you know the year, pick it. Faults for other years drop out of the list.

Before you buy

Known faults

8 important faults

critical1

On these engines the oil pump is driven by its own small toothed belt, and that belt runs in the hot engine oil. This is not the large timing belt that drives the camshafts, it is a separate belt in the lower part of the engine. In the oil the rubber hardens over time, its surface starts to crumble, and the loose particles block the suction side of the oil pump, so the oil pressure drops. If the belt snaps, the oil pump stops at once and the engine is left without lubrication within seconds. The rubber crumbs can also ruin the turbocharger and the camshaft adjuster, because they are lubricated from the same oil circuit. The maker specifies no replacement interval for this belt, so most cars still carry the one fitted at the factory, and the failures are reported above 150,000 km. Oil outside the specification and a stretched oil change speed the process up, because this belt ages in the oil. Replacing the belt itself costs between 200 and 600 euro, as long as the engine has not run without oil pressure.

above 150,000 km200–600 EUR

What to check

  • Ask whether the oil pump belt has been replaced, and if so at what mileage
  • Unscrew the oil filler cap and look for black rubber crumbs in the lubricant
  • Ask which oil was used and how often the engine was serviced
2 more steps in the write-up

expensive7

The EGR valve and its cooler block up with soot and oily deposits; the particulate filter cannot regenerate on short urban trips. The signs are reduced power, a warning light, and frequent regeneration. The software update after the diesel emissions affair made the EGR operate more often, which accelerated the phenomenon: the maker gave goodwill repairs in several cases.

between 140,000 and 160,000 km

What to check

  • Ask what kind of journeys the car did: a daily short urban run is the worst for the filter
  • With a code reader look at the stored faults (P0401/P0402, and P2002 for the filter)
  • Ask whether it received the post emissions affair software update, and when
1 more steps in the write-up

On this engine the water pump is driven by the timing belt, and the plastic impeller of the pump, along with its electronically controlled shut-off ring, is the weak point: the ring sticks, and the impeller separates from the shaft or disintegrates. The first sign is slowly disappearing coolant and heating that stays cold for a long time. The real risk is not the price of the pump: the leaking water washes the grease off the timing belt rollers, and from then on the belt is what fails. If the timing belt snaps, the engine is badly damaged inside. That is why the two are always replaced together.

What to check

  • Check the level in the expansion tank, and ask whether it needs topping up
  • After a cold start watch how long it takes for the heating to warm up
  • Shine a light under the timing belt cover: dried, whitish coolant traces mean a leak
2 more steps in the write-up

A thin wall of the mechatronics valve body can crack, which causes a loss of pressure. The typical signs: jerking and harsh shifting from 1st to 2nd at low speed, a flashing PRNDS display, then a gear engagement fault, intermittently at first.

What to check

  • Pull away slowly from standstill and watch the 1 to 2 shift: does it jerk, is it harsh
  • Check whether the PRNDS display flashes or the dash reports a gearbox fault
  • In creep mode (brake released), does the car move off evenly
1 more steps in the write-up

The internal springs of the flywheel tire, and the two discs knock against each other. The signs are a rattling or knocking from the bellhousing at idle and when releasing the clutch pedal, and vibration through the floor. If the clutch slips without a burnt smell, that also points to the flywheel. It is worth replacing in time: a disintegrated flywheel can destroy the bellhousing too. At a clutch replacement the two go together anyway.

What to check

  • At idle, without touching the clutch pedal, listen for the rattle from the bellhousing, then press the pedal: if it stops, that is suspect
  • Watch for the characteristic clatter on starting and switching off
  • Put your foot on the floor at idle: a noticeable vibration indicates tired springs
2 more steps in the write-up

The ABS control unit fails. First the ABS and ESP lights come on intermittently, then they stay on, and the stability control drops out. The fault typically appears with code `01435`: that points at the controller of the hydraulic brake unit. The unit can often be refurbished, because the fault is in the soldering. A new controller is not always needed.

What to check

  • After startup watch whether the ABS and ESP lights go out within a few seconds
  • Query the brake system with a code reader and look for code 01435
  • On the test drive brake on an uneven road: the ABS working is audible and felt through the pedal
1 more steps in the write-up

The first series Touran fails the roadworthiness test for rust more often than average, and the reports single out the tailgate. The corrosion starts along the edge and the seams, initially only as blistering paint. Added to that, oil leaks are above average on every model year and engine version, which contaminates the metal from below.

What to check

  • Open the tailgate and go along the edge all around, including the bottom
  • Feel the paint along the trim line: blistering means rust underneath
  • Have the car lifted and look at the sill and the inner lip of the wheel arches
2 more steps in the write-up

The rubber seals of the rear doors age and become porous, and the sunroof drains block up. The water gets into the rear footwell and the side wall of the boot; it stays under the carpet, so it goes unnoticed for a long time. The rear is full of electronics and trim, and the connectors corrode.

What to check

  • Lift the rear carpet and the boot floor, and feel the foam
  • Run your finger along the rubber seals of the rear doors: hard, cracked rubber is porous
  • On a car with a sunroof, pour water into the corners of the roof and see where it drains underneath
2 more steps in the write-up

cheap repair1

The dash shows "Error: Workshop! Only leave vehicle in position P" with an audible warning. The message appears in whatever language the car is set to, for example "Fehler: Werkstatt! Fahrzeug nur in Stellung P verlassen" in German.

Show the rest

The message points at the gearbox, but the fault is not there. A tiny switch sits in the module under the selector lever and signals that the lever is in park (P). Its contact wears and can also burn. That makes the signal unreliable, and the car warns you. The fault codes appear as 617752, P173400 or B116229.

At first it is intermittent. Sometimes the message comes up, sometimes not, so a short test drive easily misses it. Later it becomes permanent, and the gearbox can drop into limp mode.

This fault looks more expensive than it is. The maker released a separate retrofit switch kit for it (5Q0713128A for the black module, 3Q0713128 for the white one), which can be fitted in half an hour. The kit costs 70 to 100 pounds. At a franchised dealer, however, the whole selector lever module sometimes gets replaced, which costs 626 to 1,000 pounds there. So the difference between the two routes is roughly tenfold.

The affected group is post 2013 MQB platform Volkswagen, Audi, Seat and Skoda cars with a DSG gearbox. The switch is in these gearboxes, because that is what these cars have in common. The part itself is not part of the gearbox but of the module under the lever.

What to check

  • Watch the dash after starting: the message is intermittent and can be missed on a short loop
  • Move the lever from P to D and back several times, then get out and lock the car
  • Ask whether the selector lever switch has been replaced already, and ask for the invoice
2 more steps in the write-up

Checklist

Volkswagen Touran 1.6 TDI 105hp BMT Comfortline

First what you would check on any car. Then the faults of this model.

Before you buy

Checklist

The printed sheet starts with what you would check on any car. What you tick stays on this device only.

On every car

Ask the owner

vinkodex.com · Before you buy it, see what can go wrong.

Official recall4 recallsShow

The manufacturer fixes these for free at a franchised dealer. Ask with the VIN whether it was done.

Most recent: 7 October 2026

SR/02935/26Safety recallInjuries7 October 2026 · EU Safety Gate

Moisture ingress could lead to corrosion of a steering rack bolt, which may result in a fracture of the bolt and a loss of steering capability, increasing the risk of accidents. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: 07/10/2026

We could not check this: model year. The authority's notice

A12/00816/22Safety recallInjuriesno date · EU Safety Gate

The thickness of the gas tank walls could be reduced to below the requirements, by corrosion. Gas tanks may burst, increasing the risk of injury. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

We could not check this: model year. The authority's notice

A12/0300/17Safety recallInjuriesno date · EU Safety Gate

If mechanical damage occurs to the varnish layer of the gas tank, it could lead to the outer shell of the gas tank no longer having the required corrosion protection. With ongoing corrosion over an extended period of time, the residual wall thickness of the gas tank could become too low and the gas tank could burst.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

We could not check this: model year. The authority's notice

A12/1535/18Safety recallFireno date · EU Safety Gate

Moisture can reach the LED module of the sunroof's ambient lighting which may cause a short-circuit and a build-up of heat. If this happens, there is a risk of fire.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

We could not check this: model year. The authority's notice

Engine and transmission

CAYC · 1.6 TDI

77 kW (105 HP) · diesel

DQ200 · 7-speed DSG, dry clutch

DSG · 7 speed

Clutchdry
Torque limit250 Nm
MakerVolkswagen

We built the code from the model and the gear count. The factory sheet does not state it.

Variant data

What is in this version

Factory data

Trim
BMT Comfortline
Body
MPV
Fuel
diesel
Transmission
automatic
Engine size
1598 cc
Power
77 kW (105 HP)
Drive
FWD
Production
2010–2015

Factory service interval

The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.

  • Air filter

    • 60,000 km or 4 years
  • DQ200: lifetime fill by the maker, not in practice

    • lifetime fill: the maker does NOT specify a change
  • Cabin (pollen) filter

    • 30,000 km or 2 years
  • Engine oil and oil filter

    • LongLife30,000 km or 2 years(valid only with LongLife-approved oil)
    • 15,000 km or 1 year
  • Brake fluid change

    • first: 3 years, then 2 years(first change at 3 years, then every two years)
  • Timing belt, 1.6 / 2.0 TDI (EA188/EA189/EA288)

    • 210,000 km(EA288, including the 1.6 TDI, with no time limit. 130,000 miles = 209,215 km. Parts maker repair specification, read by a human. The interval chart at https://www.rwcmotorsport.com/tech/tdi-maintenance.php gives the same figure independently.)
  • Coolant (antifreeze) change

    • first: 193,000 km or 10 years, then 97,000 km or 5 years(G13 / G12++: first change at 120,000 miles or 10 years, then every 60,000 miles or 5 years)
  • Fuel filter, diesel

    • 60,000 km or 2 years

Information, not an expert opinion

We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.

  • A fault on the list does not mean the car you are looking at has it.
  • A fault missing from the list does not mean the model is fault-free. Write-ups are made model by model. Not all of them are done.
  • You decide whether to buy. This is no substitute for an inspection. That needs a workshop and a history check.
Details in the terms