vinkodex.

Opel Vectra 1.6i-16V Diamond common faults.

1999–2002, saloon, petrol, 100 HP.

The fault list covers: X16SZR, X16XEL, Y16XE, Z16XE engine, F17, F23 transmission.

What you save stays on this device only. My saves

2 fault write-ups. 1 important. No recall on the list.

If you know the year, pick it. Faults for other years drop out of the list.

Before you buy

Known faults

1 important faults

expensive1

F17 five speed manual gearbox: synchros and differential

expensive

The Opel F17 (and F17+) is one of the most common five speed manual gearboxes of the Astra / Corsa / Zafira era. The synchro ring and the differential wear, and so do the layshaft bearings.

Show the rest

Symptoms: a stiff or scratchy shift (mostly when warm), a whine while driving, differential noise when pulling away. Failures are more common with the stronger engines (at the limit of the F17+). Oil leaks speed up the wear: 5th gear sits high, so it is the first to be short of lubrication.

between 120,000 and 220,000 km

What to check

  • When warm, at 80 to 100 km/h, listen for gearbox whine: a noise that rises with the revs is suspect
  • Try 1 to 2 and 2 to 3 shifts cold and warm: binding, scratchiness
  • When pulling away, listen for noise or a clunk from the differential
2 more steps in the write-up

comfort1

F23 five speed manual gearbox: sticking shift and input shaft bearing

comfort

The Opel F23 (Getrag, roughly 1998 to 2011) is the five speed manual gearbox of the stronger engines in the Astra G/H, Vectra and Zafira A. The typical fault is a stiff, sticking shift.

Show the rest

A common cause is wear of the plastic guide sleeve and the selector lever sleeve, or a loose shift linkage. At high mileage (above around 200,000 km) the input shaft bearing starts to whine. With too little oil the noise gets worse. The fill is about 2 litres of API GL-4 75W-85, and the oil change is about every 60,000 km.

The F23 sticks, and the input shaft bearing whines. On the F17 the synchro ring and the differential wear.

between 150,000 and 250,000 km

What to check

  • Try every gear cold and warm: does the lever stick or bind
  • When warm, at open road speed, listen for a whine coming from the input shaft side
  • Move the selector lever in neutral: an overly loose or vague linkage is suspect
2 more steps in the write-up

Checklist

Opel Vectra 1.6i-16V Diamond

First what you would check on any car. Then the faults of this model.

Before you buy

Checklist

The printed sheet starts with what you would check on any car. What you tick stays on this device only.

On every car

Ask the owner

Faults of this model

vinkodex.com · Before you buy it, see what can go wrong.

Engine and transmission

4 engines · 2 transmissions

X16SZR · 1.6 8V

55 kW (75 HP) · petrol

F17 · 5-speed manual, transverse (Opel F17 / F17+)

manual · 5 speed

Torque limit200 Nm
MakerOpel/GM

We built the code from the model and the gear count. The factory sheet does not state it. More than one engine code is possible. The fault list shows the faults of each. More than one transmission is possible. The gear count does not tell them apart. The code is on the side of the transmission.

Variant data

What is in this version

Factory data

Trim
-16V Diamond
Body
saloon
Fuel
petrol
Transmission
manual
Engine size
1598 cc
Power
74 kW (101 HP)
Drive
FWD
Production
1999–2002

Factory service interval

The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.

  • Air filter

    • 60,000 km or 4 years

  • Cabin (pollen) filter

    • 30,000 km or 2 years

  • Brake fluid change

    • first: 3 years, then 2 years(first change at 3 years, then every two years)

  • Spark plugs, petrol

    • 60,000 km or 6 years
All B.5 versions

Information, not an expert opinion

We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.

  • A fault on the list does not mean the car you are looking at has it.
  • A fault missing from the list does not mean the model is fault-free. Write-ups are made model by model. Not all of them are done.
  • You decide whether to buy. This is no substitute for an inspection. That needs a workshop and a history check.
Details in the terms