vinkodex.

Mercedes-Benz Vito Vito short 114 CDI common faults.

2014–2024, van, diesel, 136 HP.

The fault list covers: OM654 engine, MB7250 transmission.

What you save stays on this device only. My saves

2 fault write-ups. Both are important. 9 recalls.

If you know the year, pick it. Faults for other years drop out of the list.

Before you buy

Known faults

2 important faults

critical1

OM654 / OM656: vacuum controlled coolant pump leak, fire risk

critical

On the OM654 and OM656 diesels the maker started a recall over the vacuum controlled coolant pump (maker action code: 2090008). The fault: a leak can develop between the coolant and the vacuum circuit; if coolant reaches the electric switching valves, an electrochemical reaction can raise the temperature of the part, and a fire risk cannot be ruled out.

Show the rest

The fix: replacing the electric switching valve and a software update. The campaign started at the end of 2021; the affected group is the C-Class, E-Class and other OM654/OM656 models.

A recall on the model does not mean it was carried out on this car. Only the franchised dealer can tell you, by VIN.

What to check

  • Ask the franchised dealer by VIN: is action 2090008 OPEN or CLOSED
  • Check the coolant level and look around the vacuum system for leaks
  • Ask for the service sheet: a switching valve replacement plus a software update is part of the campaign
1 more steps in the write-up

expensive1

OM654 / OM656 diesel: roller finger follower wear and DPF driven oil dilution

expensive

The modern OM654 four cylinder diesel (and the modular OM656 six cylinder) carries two weaknesses on the used market that reinforce each other.

Show the rest

1) Roller finger followers (Rollenschlepphebel). According to the German technical press, on some cars the followers wear early at around 100,000 to 120,000 km. On 10 July 2018 the maker introduced a strengthened follower from engine number 80278367 (new part number A6540505701 in place of the old A6540501100). On early built cars the risk is higher. A faulty follower develops so much heat that the removed metal shows blue discolouration (Anlaufspur).

2) Oil dilution. The post injection needed to regenerate the particulate filter puts diesel fuel into the engine oil. With short urban use the engine does not get warm enough, the fuel does not evaporate, the oil thins out, and the follower and valvetrain are exactly what suffers most from poor lubrication.

The timing chain sits on the gearbox side: if it stretches, the replacement is labour intensive. There are few complaints of a broken chain, but on the early series about 5,000 cars were recalled for a weak chain, and the Tritan 15 coating was changed to Tritan 18.

between 80,000 and 160,000 km

What to check

  • Listen to the engine on a cold start: metallic ticking or rattling from the follower or the chain is suspect
  • Ask for the engine number: cars below 80278367 (before July 2018) are the old follower group
  • Check the service book: how often and with what oil (MB 229.52 is recommended) it was changed. Long intervals plus urban use is the worst pairing
2 more steps in the write-up

Checklist

Mercedes-Benz Vito Vito short 114 CDI

First what you would check on any car. Then the faults of this model.

Before you buy

Checklist

The printed sheet starts with what you would check on any car. What you tick stays on this device only.

On every car

Ask the owner

Faults of this model

vinkodex.com · Before you buy it, see what can go wrong.

Official recall9 recallsShow

The manufacturer fixes these for free at a franchised dealer. Ask with the VIN whether it was done.

Most recent: 22 February 2022

22V099000BACK OVER PREVENTION: SENSING SYSTEM: CAMERABACK OVER PREVENTION: SENSING SYSTEM: CAMERA22 February 2022 · NHTSA (USA)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2018 Mercedes-Benz Metris vehicles. A defective memory chip in the rearview camera may cause the display image to freeze.

Risk: A frozen rearview image does not show the live view of what is currently behind the vehicle, increasing the risk of a crash.

Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed February 10, 2023. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS2RU54KAM.

The authority's notice

18V335000POWER TRAIN:AUTOMATIC TRANSMISSIONPOWER TRAIN:AUTOMATIC TRANSMISSION22 May 2018 · NHTSA (USA)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2017 Mercedes-Benz Metris vehicles. The transmission support may not have been properly tightened to the vehicle body, potentially resulting in damage to the driveshaft.

Risk: Damage to the driveshaft could cause a loss of power to the wheels, increasing the risk of a crash.

Remedy: DVUSA will notify owners, and dealers will inspect the transmission support mounting bolts, replacing and tightening them as necessary, free of charge. The recall began July 11, 2018. Owners may contact DVUSA customer service at 1-877-762-8267.

The authority's notice

17V595000STEERING:ELECTRIC POWER ASSIST SYSTEMSTEERING:ELECTRIC POWER ASSIST SYSTEM22 September 2017 · NHTSA (USA)

Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2015-2017 Mercedes-Benz Metris vans. These vehicles have electrical power steering control units with improperly welded contact pins.

Risk: The improperly welded pins may lose contact, deactivating the power steering assist and increasing the risk of a crash.

Remedy: DVUSA will notify owners, and dealers will replace the electric power steering rack, free of charge. An interim notice is expected to be mailed on November 17, 2017. A second notice will be mailed to owners when parts become available. Owners may contact Daimler's customer service at 1-877-762-8267.

The authority's notice

A12/00872/22Safety recallInjuriesno date · EU Safety Gate

Incorrect image (frozen picture) information may be displayed by the rear view camera at low temperatures. As a result, the driver will not have an accurate and reliable view of the areas behind the vehicle on the display screen when reversing, which could increase the risk of an accident The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/01278/20Safety recallInjuriesno date · EU Safety Gate

Incorrect mass values on the vehicle registration certificate may lead to overloading of the vehicle. As a result, the front and rear axles can be damaged.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/1061/17Safety recallInjuriesno date · EU Safety Gate

Missing welding points on the rear cross-bar may increase the risk of injury for passengers in the event of an accident.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/1735/17Safety recallInjuriesno date · EU Safety Gate

The steering column is not sufficiently earthed. As a result, in the event of an electrostatic discharge, the driver's airbag may be triggered when not required. This could cause an accident.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/1752/19Safety recallFireno date · EU Safety Gate

The coverings on the seat boxes with an integrated back-up battery may be missing. This will increase the risk of a short circuit or fire in case objects made of electroconductive (e.g. metal) materials are placed in the seat boxes.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/1874/17Safety recallInjuriesno date · EU Safety Gate

The cabling under the front swivel seats can get caught causing damage to the cabling. This could result in the unintended deployment of the thorax airbag when the seat is rotated causing injuries to the occupant.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

Engine and transmission

OM654

100–176 kW (136–239 HP) · diesel

MB7250 · 9G-Tronic, longitudinal (Mercedes 725.0 / NAG3)

automatic · 9 speed

Torque limit700 Nm
MakerMercedes-Benz

We built the code from the model and the gear count. The factory sheet does not state it.

Variant data

What is in this version

Factory data

Trim
Vito short 114 CDI
Body
van
Fuel
diesel
Transmission
automatic
Engine size
1950 cc
Power
100 kW (136 HP)
Drive
RWD
Production
2014–2024

Factory service interval

The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.

  • Air filter

    • 60,000 km or 4 years

  • Cabin (pollen) filter

    • 30,000 km or 2 years

  • Brake fluid change

    • first: 3 years, then 2 years(first change at 3 years, then every two years)

  • Fuel filter, diesel

    • 60,000 km or 2 years
All W447 versions

Information, not an expert opinion

We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.

  • A fault on the list does not mean the car you are looking at has it.
  • A fault missing from the list does not mean the model is fault-free. Write-ups are made model by model. Not all of them are done.
  • You decide whether to buy. This is no substitute for an inspection. That needs a workshop and a history check.
Details in the terms