vinkodex.

BMW X5 X5 3.0d Executive common faults.

2003–2007, SUV, diesel, 218 HP.

The fault list covers: M57D30TU engine, ZF6HP26 transmission.

What you save stays on this device only. My saves

1 fault write-ups. Important. 5 recalls.

If you know the year, pick it. Faults for other years drop out of the list.

Before you buy

Known faults

1 important faults

ZF 6HP automatic: mechatronics connector sealing sleeve leaks

expensive

In the ZF six speed automatic (BMW codes GA6HP19Z / GA6HP26Z) the electrical connector of the valve body control leaves the gearbox housing through a plastic sleeve. That sleeve and its seals age, and they let oil through.

Show the rest

The symptom is irregular shifting, a gear slipping at higher revs, limp mode, a drivetrain fault code and a message on the display. The cause is the same in each case: the leak drops the hydraulic pressure, and the valve body cannot close the clutches with enough force.

The sleeve can be replaced without removing the gearbox, you only have to drop the oil pan. If it leaks for a long time, the slipping clutch and the overheating pump take the inside of the gearbox with them, and from then on it is a rebuild. The factory calls the oil a lifetime fill, but in practice the sleeve wears out around 60,000 to 70,000 miles, roughly 100,000 to 115,000 km.

between 100,000 and 200,000 km

What to check

  • On a lift look at the right side of the gearbox housing, above the oil pan: a wet, oily connector is the characteristic picture
  • On the test drive watch the shifts cold and warm: jerking, delay, slipping at higher revs
  • Ask for a fault code read from the gearbox controller: gear ratio fault, pressure regulation
2 more steps in the write-up

Checklist

BMW X5 X5 3.0d Executive

First what you would check on any car. Then the faults of this model.

Before you buy

Checklist

The printed sheet starts with what you would check on any car. What you tick stays on this device only.

On every car

Ask the owner

Faults of this model

vinkodex.com · Before you buy it, see what can go wrong.

Official recall5 recallsShow

The manufacturer fixes these for free at a franchised dealer. Ask with the VIN whether it was done.

Most recent: 18 August 2004

04V409000POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)18 August 2004 · NHTSA (USA)

ON CERTAIN PASSENGER VEHICLES WITH 3.0 L ENGINES AND MANUAL TRANSMISSIONS, IF THE VEHICLE IS IN FIRST GEAR, AND MOVING SLOWLY, WITH THE ACCELERATOR PEDAL HELD IN A CONSTANT POSITION OF LOW ENGINE SPEED AND WITH THE CLUTCH PEDAL HELD IN A PARTIALLY DEPRESSED POSITION, ENGINE SPEED MAY INCREASE.

Risk: THE VEHICLE COULD ACCELERATE UNEXPECTEDLY, WHICH COULD RESULT IN A CRASH.

Remedy: DEALERS WILL REPROGRAM THE VEHICLE'S DIGITAL ENGINE MANAGEMENT CONTROL UNIT. THE RECALL BEGAN ON SEPTEMBER 8, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.

The authority's notice

04V402000FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMPFUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP13 August 2004 · NHTSA (USA)

ON CERTAIN SPORT UTILITY VEHICLES, THE IN-TANK FUEL LINE MAY HAVE BEEN ATTACHED INCORRECTLY.

Risk: ENGINE STALLING COULD OCCUR, EVEN THOUGH THE VEHICLE'S FUEL GAUGE INDICATES THAT FUEL IS PRESENT IN THE TANK. DEPENDING UPON TRAFFIC AND ROAD CONDITIONS, THIS COULD RESULT IN A CRASH.

Remedy: DEALERS WILL INSPECT THE IN-TANK SUCTION JET PUMP FUEL LINE AND IF NECESSARY, REATTACH ACCORDING TO SPECIFICATIONS. THIS RECALL BEGAN SEPTEMBER 9, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.

The authority's notice

04V344000POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)14 July 2004 · NHTSA (USA)

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 8 AND 12 CYLINDER ENGINES, THE DIGITAL ENGINE MANAGEMENT CONTROL (EMC) UNITS WERE NOT PRODUCED ACCORDING TO SPECIFICATIONS.

Risk: AS A RESULT, ENGINE STALLING WILL OCCUR AFTER A SHORT PERIOD OF OPERATION. THE VEHICLE MAY NOT BE ABLE TO RESTART. ALSO, A LOSS OF POWER STEERING AND, AFTER REPEATED ACTUATION OF THE BRAKE PEDAL, A LOSS OF BRAKE POWER ASSIST WILL OCCUR. THESE CONDITIONS COULD RESULT IN A VEHICLE CRASH.

Remedy: DEALERS WILL INSTALL A NEW DIGITAL ENGINE MANAGEMENT CONTROL UNIT. THE RECALL BEGAN ON JULY 16, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.

The authority's notice

03V475000POWER TRAIN:DRIVELINE:DIFFERENTIAL UNITPOWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT14 November 2003 · NHTSA (USA)

ON CERTAIN SPORT UTILITY VEHICLES, THE BOLTS THAT HOLD THE FRONT DIFFERENTIAL, THE RIGHT OUTPUT SHAFT HOUSING FLANGE AT THE ENGINE, AND THE RIGHT-HAND ENGINE SUPPORT MAY BE INSUFFICIENTLY TIGHTENED.

Risk: WITH PROLONGED DRIVING, THESE BOLTS COULD BECOME LOOSE, CAUSE DAMAGE TO THE ENGINE AND TRANSMISSION HOUSINGS. THE RIGHT OUTPUT SHAFT COULD BECOME DISCONNECTED, AFFECTING THE ABILITY TO CONTROL THE VEHICLE, WHICH COULD RESULT IN A CRASH.

Remedy: DEALERS WILL INSPECT AND RETIGHTEN THE DRIVETRAIN FASTENERS. OWNER NOTIFICATION BEGAN NOVEMBER 28, 2003. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.

The authority's notice

A12/0484/19Safety recallInjuriesno date · EU Safety Gate

Owing to retrofitting of the steering wheel, certain vehicles may be equipped with a driver airbag that has a gas generator which could burst in the event of airbag activation if it has been exposed to moisture and heat cycles over time. This may result in metal parts being discharged, which could lead to injury or death of the vehicle occupants.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

Engine and transmission

M57D30TU · 3.0d

160 kW (218 HP) · diesel

ZF6HP26 · 6-speed automatic, longitudinal (ZF 6HP26, BMW GA6HP26)

automatic · 6 speed

Torque limit650 Nm
MakerZF

We built the code from the model and the gear count. The factory sheet does not state it.

Variant data

What is in this version

Factory data

Trim
X5 3.0d Executive
Body
SUV
Fuel
diesel
Transmission
automatic
Engine size
2993 cc
Power
160 kW (218 HP)
Drive
AWD
Production
2003–2007

Factory service interval

The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.

  • Air filter

    • 60,000 km or 4 years

  • Cabin (pollen) filter

    • 30,000 km or 2 years

  • Brake fluid change

    • first: 3 years, then 2 years(first change at 3 years, then every two years)

  • Engine oil and oil filter (BMW condition-based service)

    • LongLife25,000 km or 2 years

  • Fuel filter, diesel

    • 60,000 km or 2 years
All E53 versions

Information, not an expert opinion

We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.

  • A fault on the list does not mean the car you are looking at has it.
  • A fault missing from the list does not mean the model is fault-free. Write-ups are made model by model. Not all of them are done.
  • You decide whether to buy. This is no substitute for an inspection. That needs a workshop and a history check.
Details in the terms