vinkodex.

Opel Astra 1.2 Turbo 130hp Design & Tech common faults.

2019–2021, hatchback, petrol, 130 HP.

The fault list covers: EB2ADTS, F12SHT engine, F17, M32, M22 transmission.

What you save stays on this device only. My saves

3 fault write-ups. All are important. 3 recalls.

If you know the year, pick it. Faults for other years drop out of the list.

Before you buy

Known faults

3 important faults

critical1

1.2 PureTech / DI Turbo (EB2*): wet timing belt

critical

Opel's post 2017 PSA platform 1.2 litre turbo petrol engines (PureTech / 1.2 Direct Injection Turbo, engine codes EB2*) run the timing belt in engine oil. According to the AUTO BILD and ADAC technical tables this design also appears in the Grandland, Crossland, Corsa F, Mokka B and Astra L ranges.

Show the rest

The belt swells, cracks or sheds material early: the particles clog the oil filter and the oil pickup, the oil pressure drops, and in the extreme case the belt breaks and the engine is badly damaged inside. Short trip use (fuel in the oil) and the wrong oil specification raise the risk.

A strengthened belt arrived in 2022; from 2023 the third generation 1.2 Turbo (and the 48V mild hybrid) switched to a chain, and this does not apply to those. Check whether the car has the belt or the post 2023 chain, and when the belt and the oil filter were last changed.

between 60,000 and 120,000 km

What to check

  • Establish the engine code or the VIN: EB2* means a wet belt; the 2023 and later chain or mild hybrid generation does not have this belt
  • Ask for a wet belt inspection (through the oil filler, with a gauge): a swollen belt means immediate replacement
  • Check the service book: the specified oil grade changed in mid 2021, and the short oil change interval matters
3 more steps in the write-up

expensive2

Astra H: M32 six speed manual, bearing and synchro wear

expensive

In the Astra H diesel range, on the Z17DTH engine, two manual gearboxes were available: the five speed F23 and the six speed M32.

Show the rest

The known weakness of the M32 is wear of the bearings and the synchro rings: a whine while driving, a stiff shift, especially 3rd to 4th. Replacement or a rebuild is expensive.

between 100,000 and 200,000 km

What to check

  • Count the gears: 6 raises the M32 suspicion on this engine group; 5 means more likely the F23
  • When warm, at 80 to 100 km/h, listen for gearbox whine: a noise that rises with the revs is suspect
  • Try the 3 to 4 and 4 to 5 shifts cold and warm: binding, scratchiness
1 more steps in the write-up

F17 five speed manual gearbox: synchros and differential

expensive

The Opel F17 (and F17+) is one of the most common five speed manual gearboxes of the Astra / Corsa / Zafira era. The synchro ring and the differential wear, and so do the layshaft bearings.

Show the rest

Symptoms: a stiff or scratchy shift (mostly when warm), a whine while driving, differential noise when pulling away. Failures are more common with the stronger engines (at the limit of the F17+). Oil leaks speed up the wear: 5th gear sits high, so it is the first to be short of lubrication.

between 120,000 and 220,000 km

What to check

  • When warm, at 80 to 100 km/h, listen for gearbox whine: a noise that rises with the revs is suspect
  • Try 1 to 2 and 2 to 3 shifts cold and warm: binding, scratchiness
  • When pulling away, listen for noise or a clunk from the differential
2 more steps in the write-up

Checklist

Opel Astra 1.2 Turbo 130hp Design & Tech

First what you would check on any car. Then the faults of this model.

Before you buy

Checklist

The printed sheet starts with what you would check on any car. What you tick stays on this device only.

On every car

Ask the owner

Faults of this model

vinkodex.com · Before you buy it, see what can go wrong.

Official recall3 recallsShow

The manufacturer fixes these for free at a franchised dealer. Ask with the VIN whether it was done.

Most recent: 3 July 2025

SR/02659/25Safety recallInjuries3 July 2025 · EU Safety Gate

Due to oil carbonisation and high contact pressure, the 7 mm camshaft chain resistance can be reduced. This may cause the camshaft chain to break, leading to an engine failure. This can cause a loss of vehicle's control and increase the risk of accidents and injuries. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: 03/07/2025

The authority's notice

A12/01877/23Safety recallEnvironment19 June 2023 · EU Safety Gate

A software error in the engine control unit prevents the malfunction indicator light (MIL) from switching on if the urea injector stops working. This can lead to higher emissions and poses a risk to the environment. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: 19/06/2023

The authority's notice

A12/00135/21Safety recallInjuriesno date · EU Safety Gate

The wheel screws are not tightened with the required torque. This could lead to a wheel being lost during driving, increasing the risk of an accident.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

Engine and transmission

2 engines · 3 transmissions

EB2ADTS · 1.2 DI Turbo

96–100 kW (131–136 HP) · petrol

F17 · 5-speed manual, transverse (Opel F17 / F17+)

manual · 5 speed

Torque limit200 Nm
MakerOpel/GM

We built the code from the model and the gear count. The factory sheet does not state it. More than one engine code is possible. The fault list shows the faults of each. More than one transmission is possible. The gear count does not tell them apart. The code is on the side of the transmission.

Variant data

What is in this version

Factory data

Trim
Design & Tech
Body
hatchback
Fuel
petrol
Transmission
manual
Engine size
1199 cc
Power
96 kW (131 HP)
Drive
FWD
Production
2019–2021

Factory service interval

The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.

  • Air filter

    • 60,000 km or 4 years

  • Cabin (pollen) filter

    • 30,000 km or 2 years

  • Brake fluid change

    • first: 3 years, then 2 years(first change at 3 years, then every two years)

  • Spark plugs, petrol

    • 60,000 km or 6 years
All K versions

Information, not an expert opinion

We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.

  • A fault on the list does not mean the car you are looking at has it.
  • A fault missing from the list does not mean the model is fault-free. Write-ups are made model by model. Not all of them are done.
  • You decide whether to buy. This is no substitute for an inspection. That needs a workshop and a history check.
Details in the terms