vinkodex.

Volkswagen Caddy L2H1 1.4 TSI common faults.

2015–2020, van, petrol, 125 HP.

The fault list covers: CZCA engine, MQ200 transmission.

What you save stays on this device only. My saves

5 fault write-ups. 3 important. 4 recalls.

If you know the year, pick it. Faults for other years drop out of the list.

Before you buy

Known faults

3 important faults

expensive3

MQ200 / MQ250 manual gearbox: differential bearing and synchros

expensive

The light, magnesium cased MQ200 and the MQ250, sized for higher torque, are the most widespread manual gearboxes in the transverse engine VAG models. Both have the same two weak points, and both depend on use.

Show the rest

The first is the differential bearing: as it wears you first get a droning, then a whine from the thrust bearings of the output shaft. Left alone, the planetary shaft can fail and in extreme cases punch through the gearbox casing: from then on it is not a repair but a replacement.

The second is the synchros: they can start crunching at around 50,000 km with aggressive driving. This type does not like dumping the clutch or slipping it, and on a used car that is exactly what you have to listen for.

above 50,000 km

What to check

  • On the test drive with the window down, listen to the gearbox both off and on the throttle: droning or whining is suspect
  • Shift up and down quickly, especially into 2nd and 3rd: crunching means synchro wear
  • Try engaging 1st and reverse when cold: resistance here means wear
2 more steps in the write-up

EA211 (1.0 to 1.5 TSI): water pump and thermostat module leak

expensive

In the EA211 the water pump and the thermostat are one plastic module, and the pump is driven not by the timing belt but by a separate toothed belt behind the exhaust camshaft. There are usually two problems with it: the plastic housing warps or cracks (slow coolant loss, a sweet smell, rising temperature), or the drive belt ages (a chirping noise, then an engine left with no cooling). The housing is particularly sensitive if oil reaches it: for example from a leaking crankcase ventilation. The module has to be replaced whole: dismantling it warps it in itself.

What to check

  • Check the level in the expansion tank, and ask whether it needs topping up
  • After a cold start smell the engine bay: a sweet smell means coolant
  • Look for dried, whitish pink deposits on the exhaust side of the cylinder head
2 more steps in the write-up

Heater matrix and radiator leak

expensive

The two weak points of the cooling system are the radiator and the heater matrix. The latter is inside the cabin: if it leaks, you get a sweet antifreeze smell, the windscreen mists up greasily from inside, and damp stays under the passenger side carpet. The damp goes unnoticed for a long time under the floor covering. And replacing the heater matrix means stripping the dashboard.

What to check

  • Turn the heating to maximum and smell it: a sweet smell means antifreeze
  • Check whether the inside of the windscreen mists up greasily while heating
  • Feel the passenger side carpet in the footwell, at the edges too
2 more steps in the write-up

cheap repair2

Rear leaf spring and trailing arm bush fatigue

cheap repair

The Caddy has leaf springs at the back, because it was designed to carry loads, and that is exactly the part that tires from the way it is used. The sign of a tired spring is that the back of the car sits down even unladen (the rear wheel "sinks" into the arch), and a dull clonking or knocking is audible from the rear over bumps. The spring mount and the trailing arm bushes make the same noise. On a heavily loaded fleet car it is effectively a wear item; and a tired rear suspension wears the tyre unevenly too.

What to check

  • Put it on level ground and measure the arch height on the left and right: a difference points to a tired spring
  • Check whether the back sits down unladen: a low rear against the original means a tired spring
  • Go slowly over a speed hump with the window open and listen for the clonk from the rear
2 more steps in the write-up

Sliding door: wear of the lower roller and the guide rail

cheap repair

The Caddy sliding door is opened many times a day, and the lower roller carries the weight of the door. That is what wears first: the door is hard to start moving, it grinds, it sticks halfway, and finally it "drops". The door gap visibly differs at the top and the bottom. If the mounting of the guide rail works loose, the door presses against the body, and a rub mark is left on the paint. If the roller is not replaced, the hinge and the bodywork are damaged too. On a version with a sliding door on both sides, check both.

What to check

  • Open and close the sliding door several times, fully and slowly: both binding and grinding are signs
  • Lift the door while it is open: vertical play shows wear of the lower roller
  • Look at the door gap at the top and the bottom: a difference means the door has dropped
2 more steps in the write-up

Checklist

Volkswagen Caddy L2H1 1.4 TSI

First what you would check on any car. Then the faults of this model.

Before you buy

Checklist

The printed sheet starts with what you would check on any car. What you tick stays on this device only.

On every car

Ask the owner

Faults of this model

vinkodex.com · Before you buy it, see what can go wrong.

Official recall4 recallsShow

The manufacturer fixes these for free at a franchised dealer. Ask with the VIN whether it was done.

A12/00220/20Safety recallInjuriesno date · EU Safety Gate

Cars initially used for internal purposes of Volkswagen AG might not have been correctly modified before they were sold to the general public. There is a possibility that certain safety systems of these cars are not correctly modified for street use.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

We could not check this: model year. The authority's notice

A12/00221/20Safety recallInjuriesno date · EU Safety Gate

Cars initially used for internal purposes of Volkswagen AG might not have been correctly modified before they were sold to the general public. There is a possibility that certain safety systems of these cars are not correctly modified for street use.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

We could not check this: model year. The authority's notice

A12/0590/19Safety recallInjuriesno date · EU Safety Gate

The predetermined break point in the cushion for the side airbags is on the wrong side. In the event of a crash, the side airbag may not inflate properly, thus not provide protection and increase the risk of an injury.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

We could not check this: model year. The authority's notice

A12/0774/18Safety recallInjuriesno date · EU Safety Gate

The fastening of the active headrest may be defective. In the event of an accident, the headrest may become detached from the back of the seat, increasing the risk of injury to the person occupying the seat.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

We could not check this: model year. The authority's notice

Engine and transmission

CZCA · 1.4 TFSI

92 kW (125 HP) · petrol

MQ200 · 5- or 6-speed manual

manual · 5–6 speed

Torque limit200 Nm
MakerVolkswagen

We built the code from the model and the gear count. The factory sheet does not state it.

Variant data

What is in this version

Factory data

Trim
L2H1 1.4 TSI
Body
van
Fuel
petrol
Transmission
manual
Engine size
1395 cc
Power
92 kW (125 HP)
Drive
FWD
Production
2015–2020

Factory service interval

The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.

  • Air filter

    • 60,000 km or 4 years

  • Cabin (pollen) filter

    • 30,000 km or 2 years

  • Engine oil and oil filter

    • LongLife30,000 km or 2 years(valid only with LongLife-approved oil)
    • 15,000 km or 1 year

  • Brake fluid change

    • first: 3 years, then 2 years(first change at 3 years, then every two years)

  • Coolant (antifreeze) change

    • first: 193,000 km or 10 years, then 97,000 km or 5 years(G13 / G12++: first change at 120,000 miles or 10 years, then every 60,000 miles or 5 years)

  • Spark plugs, petrol

    • 60,000 km or 6 years
All IV versions

Information, not an expert opinion

We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.

  • A fault on the list does not mean the car you are looking at has it.
  • A fault missing from the list does not mean the model is fault-free. Write-ups are made model by model. Not all of them are done.
  • You decide whether to buy. This is no substitute for an inspection. That needs a workshop and a history check.
Details in the terms