vinkodex.

Mercedes-Benz E-Class E 200 d common faults.

2020–2022, saloon, diesel, 160 HP.

The fault list covers: OM654D16SCR engine, MB7250 transmission.

What you save stays on this device only. My saves

3 fault write-ups. All are important. 15 recalls.

If you know the year, pick it. Faults for other years drop out of the list.

Before you buy

Known faults

3 important faults

critical1

OM654 / OM656: vacuum controlled coolant pump leak, fire risk

critical

On the OM654 and OM656 diesels the maker started a recall over the vacuum controlled coolant pump (maker action code: 2090008). The fault: a leak can develop between the coolant and the vacuum circuit; if coolant reaches the electric switching valves, an electrochemical reaction can raise the temperature of the part, and a fire risk cannot be ruled out.

Show the rest

The fix: replacing the electric switching valve and a software update. The campaign started at the end of 2021; the affected group is the C-Class, E-Class and other OM654/OM656 models.

A recall on the model does not mean it was carried out on this car. Only the franchised dealer can tell you, by VIN.

What to check

  • Ask the franchised dealer by VIN: is action 2090008 OPEN or CLOSED
  • Check the coolant level and look around the vacuum system for leaks
  • Ask for the service sheet: a switching valve replacement plus a software update is part of the campaign
1 more steps in the write-up

expensive2

OM654 / OM656 diesel: roller finger follower wear and DPF driven oil dilution

expensive

The modern OM654 four cylinder diesel (and the modular OM656 six cylinder) carries two weaknesses on the used market that reinforce each other.

Show the rest

1) Roller finger followers (Rollenschlepphebel). According to the German technical press, on some cars the followers wear early at around 100,000 to 120,000 km. On 10 July 2018 the maker introduced a strengthened follower from engine number 80278367 (new part number A6540505701 in place of the old A6540501100). On early built cars the risk is higher. A faulty follower develops so much heat that the removed metal shows blue discolouration (Anlaufspur).

2) Oil dilution. The post injection needed to regenerate the particulate filter puts diesel fuel into the engine oil. With short urban use the engine does not get warm enough, the fuel does not evaporate, the oil thins out, and the follower and valvetrain are exactly what suffers most from poor lubrication.

The timing chain sits on the gearbox side: if it stretches, the replacement is labour intensive. There are few complaints of a broken chain, but on the early series about 5,000 cars were recalled for a weak chain, and the Tritan 15 coating was changed to Tritan 18.

between 80,000 and 160,000 km

What to check

  • Listen to the engine on a cold start: metallic ticking or rattling from the follower or the chain is suspect
  • Ask for the engine number: cars below 80278367 (before July 2018) are the old follower group
  • Check the service book: how often and with what oil (MB 229.52 is recommended) it was changed. Long intervals plus urban use is the worst pairing
2 more steps in the write-up

Airmatic air suspension: leaking air spring, overworked compressor

expensive

The Mercedes Airmatic system holds the ride height with air springs and electronically controlled dampers. The most common faults over time are the relay, the compressor and a leaking air spring or air line.

Show the rest

The rear air springs of the 2003 to 2009 E-Class (W211) are particularly prone to leaking along the clamps. If the system leaks, the compressor runs continuously, overheats and fails, so an unrepaired leak takes the compressor with it.

Symptoms: one corner of the car sinks by morning, an "Air Suspension" or level control fault message, and compressor noise while standing. It was an option (or standard) across several generations from the W220 S-Class onwards; the estate E-Class often has air springs with level control on the rear axle as standard.

between 100,000 and 220,000 km

What to check

  • In the morning, before setting off, look at all four corners: an uneven stance means a suspected leak
  • With the car standing, listen to the compressor: continuous running indicates it is overworked
  • Ask for a fault code read on the suspension controller (level and pressure sensor codes of the C1132 / C1144 kind)
3 more steps in the write-up

Checklist

Mercedes-Benz E-Class E 200 d

First what you would check on any car. Then the faults of this model.

Before you buy

Checklist

The printed sheet starts with what you would check on any car. What you tick stays on this device only.

On every car

Ask the owner

Faults of this model

vinkodex.com · Before you buy it, see what can go wrong.

Official recall15 recallsShow

The manufacturer fixes these for free at a franchised dealer. Ask with the VIN whether it was done.

Most recent: 9 February 2024

24V100000ELECTRICAL SYSTEM:WIRINGELECTRICAL SYSTEM:WIRING9 February 2024 · NHTSA (USA)

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2021-2023 CLS450, E450, E450 All-Terrain, AMG E53, AMG GT43, AMG GT53, and 2021 AMG CLS53 vehicles. The 48-volt ground cable connection located in the engine compartment may not be tightened properly and may result in the ground cable overheating.

Risk: An overheated ground cable increases the risk of a fire.

Remedy: Dealers will inspect the 48-volt ground cable connection and repair it as necessary, free of charge. Owner notification letters were mailed March 22, 2024. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2024MMNNNN.

The authority's notice

22V733000ELECTRICAL SYSTEM:12V/24V/48V BATTERYELECTRICAL SYSTEM:12V/24V/48V BATTERY30 September 2022 · NHTSA (USA)

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2019-2022 CLS450 Coupe and AMG E53, 2019-2021 AMG CLS53 Coupe, and 2021-2022 E450 vehicles. The 12-Volt battery in the trunk may not be properly secured, which, in the event of a crash, can cause electrical connection failure, disabling various safety features including, emergency call (eCall) system, electric seat adjustment, hazard warning lights, and automatic door locks.

Risk: The inability to operate safety features (eCall system, hazard lights, electric seats, or automatic door locks) can increase the risk of injury during a crash.

Remedy: Dealers will secure the 12V battery, free of charge. Owner notification letters were mailed January 20, 2023. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2022100009.

The authority's notice

22V189000STEERING: STEERING WHEEL/HANDLE BARSTEERING: STEERING WHEEL/HANDLE BAR25 March 2022 · NHTSA (USA)

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2021-2022 C-Class, E-Class, S-Class, SL, EClass Coupe/Convertible, CLS, AMG GT 4-doors Coupe, and EQS vehicles with a heated leather steering wheel. Due to a software error in the hand detection control unit, the hands-off detection might not detect when the driver's hands are away from the steering wheel when using the Active Distance Assist DISTRONIC system.

Risk: Deactivated hands-off detection will prevent DISTRONIC system features from functioning, including warnings to grab the steering wheel and calling first responders as part of the Active Emergency Stop Assist, which can increase the risk of a crash or injury.

Remedy: Dealers will update the hand detection control unit software for the DISTRONIC system, free of charge. Owner notification letters were mailed May 6, 2022. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2022040010.

The authority's notice

A12/01658/21Safety recallInjuries2 November 2021 · EU Safety Gate

In certain vehicles with a calliper disc-brake system, the bolts of the brake callipers on the front axle may not meet the specifications. A brake calliper can detach during braking, which may lead to braking power being reduced and components being lost. That would increase the potential risk of accidents, including for the following traffic. The product does not comply with the requirements laid down in the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.

Remedy: Type of economic operator taking notified measure(s): Distributor Category of measure(s): Recall of the product from end users Date of entry into force: 02/11/2021

The authority's notice

21V406000SEATS:MID/REAR ASSEMBLY:HEAD RESTRAINTSEATS:MID/REAR ASSEMBLY:HEAD RESTRAINT28 May 2021 · NHTSA (USA)

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2021 C300 Cabriolet, C43 AMG Cabriolet, C63 AMG Cabriolet, C63 AMG S Cabriolet, E450 Cabriolet, and E53 AMG Cabriolet vehicles. The rear headrests may be incorrectly mounted to the seatbacks.

Risk: Incorrectly mounted headrests could move or detach from the seat during a crash, increasing the risk of injury.

Remedy: Dealers will inspect the rear seatback guide bushings and replace them if necessary, free of charge. Owner notification letters were mailed July 16, 2021. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2021060010.

The authority's notice

21V228000BACK OVER PREVENTION: SENSING SYSTEM: CAMERABACK OVER PREVENTION: SENSING SYSTEM: CAMERA1 April 2021 · NHTSA (USA)

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2021 E350, E450, E450 Wagon, and AMG E63 vehicles. The parking control unit may fail to display the rearview camera image and cause the parking sensors to misidentify or fail to detect objects.

Risk: An inoperative rearview camera display and/or parking sensors can reduce the driver's view and awareness of what is behind the vehicle, increasing the risk of a crash.

Remedy: All affected vehicles are still within MBUSA's control. MBUSA will replace the parking control unit, free of charge. The recall began April 8, 2021. Owner may contact MBUSA customer service at 1-800-367-6372.

The authority's notice

21V216000SEATSSEATS26 March 2021 · NHTSA (USA)

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2021 E350, E450, E450 Wagon, E63S AMG, 2020 E63S AMG Wagon, and 2020-2021 E53 AMG vehicles. The passenger seat limiter may allow the seat to be positioned too close to the air bag.

Risk: A seat too close to the air bag increases the risk of injury in the event of a crash necessitating the deployment of the frontal passenger air bag.

Remedy: MBUSA will notify owners, and dealers will recalibrate the passenger seat limiter, free of charge. The recall began April 29, 2021. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2021040002.

The authority's notice

20V673000SEATSSEATS30 October 2020 · NHTSA (USA)

Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2021 E350 and E450, 2019-2021 AMG E53 and 2020-2021 AMG E63 vehicles. The front passenger seat may be missing the mechanical seat adjustment range limit stop, allowing the seat to move outside of the acceptable range in relation to the air bag.

Risk: If the front passenger seat is adjusted beyond the acceptable range in relation to the air bag, there could be an increased risk of injury in the event of a crash with air bag deployment.

Remedy: MBUSA will notify owners, and dealers will inspect for the mechanical seat adjustment range limitation for the front passenger seat and install it if necessary, free of charge. The recall began December 18, 2020. Owners may contact MBUSA customer service at 1-800-368-6372. MBUSA's number for this recall is 2020110013.

The authority's notice

A12/00045/22Safety recallFireno date · EU Safety Gate

The vacuum-controlled coolant pump may not be tightly sealed between the coolant and vacuum circuits. This may result in the coolant leaking into the vacuum circuit leading to an electrochemical reaction, increasing the risk of fire. The product does not comply with the requirements laid down in the Regulation on the approval and market surveillance of Motor Vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/00463/24Safety recallEnvironment, Fireno date · EU Safety Gate

The 48V ground cable bolt in the engine compartment may be incorrectly secured. This could increase electrical transition resistance at the point of connection. As a result, the high electrical currents that can flow through this connection could increase the temperature, increasing the risk of fire. Furthermore, the 48V electrical power supply failure may increase exhaust emissions. This could have a negative impact on the environment. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/00888/21Safety recallInjuriesno date · EU Safety Gate

The rear head rests might not have been attached correctly. As a result, they could become displaced or detached from the seat in the event of an accident, increasing the risk of injury.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/00901/22Safety recallFire, Injuriesno date · EU Safety Gate

The screw connection of the 48 V ground connector of the coolant electric compressor may come loose and lead to improper attachment of the ground line cable head. This increases the electrical contact resistance and can cause the temperature at the connection point to increase, increasing the risk of fire. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/01532/21Safety recallInjuriesno date · EU Safety Gate

The belt tensioner arm may have been manufactured with a borderline tolerance, which could cause one side of the V-ribbed belt to rub against the belt tensioner, causing it to fail. As a result, the coolant pump may stop working, causing the engine to overheat, thus compromising the impermeability of the oil sump. Consequently, oil may leak onto the road, posing a risk to the following traffic. The product does not comply with the requirements laid down in the Regulation on the approval and market surveillance of Motor Vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/01603/21Safety recallInjuriesno date · EU Safety Gate

The mounting screws of the disc brake callipers on the front axle may not be in line with specifications. As a result, when braking, a disc brake calliper may detach, increasing the risk of accidents. The product does not comply with the requirements laid down in the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/01979/24Safety recallFireno date · EU Safety Gate

The electrical connector of the transmission wiring harness may not have been correctly processed. This can lead to water entering the connector, which could cause short circuit and can create a thermal overload of the connector when the vehicle is parked, causing the risk of fire. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

Engine and transmission

OM654D16SCR

118 kW (160 HP) · diesel

MB7250 · 9G-Tronic, longitudinal (Mercedes 725.0 / NAG3)

automatic · 9 speed

Torque limit700 Nm
MakerMercedes-Benz

We built the code from the model and the gear count. The factory sheet does not state it.

Variant data

What is in this version

Factory data

Trim
E 200 d
Body
saloon
Fuel
diesel
Transmission
automatic
Engine size
1598 cc
Power
118 kW (160 HP)
Drive
RWD
Production
2020–2022

Factory service interval

The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.

  • Air filter

    • 60,000 km or 4 years

  • Cabin (pollen) filter

    • 30,000 km or 2 years

  • Brake fluid change

    • first: 3 years, then 2 years(first change at 3 years, then every two years)

  • Fuel filter, diesel

    • 60,000 km or 2 years
All W213 versions

Information, not an expert opinion

We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.

  • A fault on the list does not mean the car you are looking at has it.
  • A fault missing from the list does not mean the model is fault-free. Write-ups are made model by model. Not all of them are done.
  • You decide whether to buy. This is no substitute for an inspection. That needs a workshop and a history check.
Details in the terms