vinkodex.

Ford Fiesta 1.5 TDCi Connected common faults.

2017–2022, hatchback, diesel, 85 HP.

The fault list covers: XUJE, XUJC, XUJD, XUJF, XUJG, XUJK, XUJL, XUJM, XUJN engine, 6MX65, B6-PLUS transmission.

What you save stays on this device only. My saves

2 fault write-ups. Both are important. 2 recalls.

If you know the year, pick it. Faults for other years drop out of the list.

Before you buy

Known faults

2 important faults

6MX65 manual: fast-wearing synchros on the first two gears

expensive

The gearbox is new, so data on its failures is still limited. The known fault is fast wear of the synchros on the first two gears, which makes shifting grate and snag.

Show the rest

The manufacturer revised the design, and since 2022 the gearbox has been much more reliable. The oil level is worth watching, because it holds very little oil and even a small leak soon brings the level to a critical point.

What to check

  • While rolling, change down into first and second: grating means worn synchros
  • Try it from cold too: the wear is more obvious then
  • Look at the gearbox housing from underneath: it holds very little oil, so a leak turns critical fast
1 more steps in the write-up

B6 Plus manual: the front input shaft bearing and the first-gear synchro

expensive

The gearbox is relatively new, so there is still little data on its failures. The weak point known so far is the front input shaft bearing.

Show the rest

Beyond that the first-gear synchro can wear quickly. The oil level is worth watching, because the gearbox holds little oil, so even a small leak soon brings the level to a critical point. The versions come with a dual-mass flywheel, which is not the most durable part.

What to check

  • At a steady speed, listen for noise: a worn input shaft bearing drones
  • While rolling slowly, change down into first: grating means a worn synchro
  • Look at the gearbox housing from underneath: it holds little oil, so a leak turns critical fast
1 more steps in the write-up

Checklist

Ford Fiesta 1.5 TDCi Connected

First what you would check on any car. Then the faults of this model.

Before you buy

Checklist

The printed sheet starts with what you would check on any car. What you tick stays on this device only.

On every car

Ask the owner

Faults of this model

vinkodex.com · Before you buy it, see what can go wrong.

Official recall2 recallsShow

The manufacturer fixes these for free at a franchised dealer. Ask with the VIN whether it was done.

Most recent: 20 December 2024

24V951000BACK OVER PREVENTION: SENSING SYSTEM: CAMERABACK OVER PREVENTION: SENSING SYSTEM: CAMERA20 December 2024 · NHTSA (USA)

Ford Motor Company (Ford) is recalling certain 2019 Flex, Fiesta, and Lincoln MKT vehicles. The rearview camera may intermittently display a blank or distorted image.

Risk: A rearview camera that displays a blank or distorted image can reduce the drivers view of what is behind the vehicle, increasing the risk of a crash.

Remedy: Dealers will replace the rearview camera as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed January 22, 2025. A second notice will be sent once the final remedy is available, anticipated March 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S75.

We could not check this: model year. The authority's notice

19V629000SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPERSERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER28 August 2019 · NHTSA (USA)

Ford Motor Company (Ford) is recalling certain 2019 Fiesta vehicles. The brake calipers may have been manufactured with the incorrect assembly fluid, which can cause the caliper's rubber seals to swell.

Risk: The swollen seals can cause the brakes to drag, potentially overheating the brakes and increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will flush the brake fluid and replace the front brake calipers and brake hoses, free of charge. The recall began October 10, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S27.

We could not check this: model year. The authority's notice

Engine and transmission

9 engines · 2 transmissions

XUJE · 1.5 TDCI

63 kW (86 HP) · diesel

6MX65 · 6-speed manual

manual · 6 speed

Torque limit240 Nm
MakerFord/Getrag

We built the code from the model and the gear count. The factory sheet does not state it. More than one engine code is possible. The fault list shows the faults of each. More than one transmission is possible. The gear count does not tell them apart. The code is on the side of the transmission.

Variant data

What is in this version

Factory data

Trim
Connected
Body
hatchback
Fuel
diesel
Transmission
manual
Engine size
1499 cc
Power
63 kW (86 HP)
Drive
FWD
Production
2017–2022

Factory service interval

The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.

  • Air filter

    • 60,000 km or 4 years

  • Cabin (pollen) filter

    • 30,000 km or 2 years

  • Brake fluid change

    • first: 3 years, then 2 years(first change at 3 years, then every two years)

  • Fuel filter, diesel

    • 60,000 km or 2 years
All Mk8 versions

Information, not an expert opinion

We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.

  • A fault on the list does not mean the car you are looking at has it.
  • A fault missing from the list does not mean the model is fault-free. Write-ups are made model by model. Not all of them are done.
  • You decide whether to buy. This is no substitute for an inspection. That needs a workshop and a history check.
Details in the terms