vinkodex.

Volkswagen Golf Sportsvan 1.4 TSI 125hp Comfortline common faults.

2014–2018, MPV, petrol, 125 HP.

The fault list covers: CZCA engine, MQ200 transmission.

What you save stays on this device only. My saves

5 fault write-ups. 2 important. 1 recalls.

If you know the year, pick it. Faults for other years drop out of the list.

Before you buy

Known faults

2 important faults

expensive2

MQ200 / MQ250 manual gearbox: differential bearing and synchros

expensive

The light, magnesium cased MQ200 and the MQ250, sized for higher torque, are the most widespread manual gearboxes in the transverse engine VAG models. Both have the same two weak points, and both depend on use.

Show the rest

The first is the differential bearing: as it wears you first get a droning, then a whine from the thrust bearings of the output shaft. Left alone, the planetary shaft can fail and in extreme cases punch through the gearbox casing: from then on it is not a repair but a replacement.

The second is the synchros: they can start crunching at around 50,000 km with aggressive driving. This type does not like dumping the clutch or slipping it, and on a used car that is exactly what you have to listen for.

above 50,000 km

What to check

  • On the test drive with the window down, listen to the gearbox both off and on the throttle: droning or whining is suspect
  • Shift up and down quickly, especially into 2nd and 3rd: crunching means synchro wear
  • Try engaging 1st and reverse when cold: resistance here means wear
2 more steps in the write-up

EA211 (1.0 to 1.5 TSI): water pump and thermostat module leak

expensive

In the EA211 the water pump and the thermostat are one plastic module, and the pump is driven not by the timing belt but by a separate toothed belt behind the exhaust camshaft. There are usually two problems with it: the plastic housing warps or cracks (slow coolant loss, a sweet smell, rising temperature), or the drive belt ages (a chirping noise, then an engine left with no cooling). The housing is particularly sensitive if oil reaches it: for example from a leaking crankcase ventilation. The module has to be replaced whole: dismantling it warps it in itself.

What to check

  • Check the level in the expansion tank, and ask whether it needs topping up
  • After a cold start smell the engine bay: a sweet smell means coolant
  • Look for dried, whitish pink deposits on the exhaust side of the cylinder head
2 more steps in the write-up

comfort1

Navigation, infotainment and electrical faults

comfort

The navigation and entertainment system freezes or restarts, and smaller electrical faults appear alongside it. The hourly rate for fault finding makes up the bigger part of the bill. A software update resolves many cases.

What to check

  • Switch the system on and try everything: radio, Bluetooth, reversing camera, navigation
  • Leave it running for ten minutes and watch whether it freezes or restarts
  • Try it after a cold start too: the fault often appears then
1 more steps in the write-up

cheap repair2

The fuel flap will not open: cable and lock mechanism

cheap repair

The release mechanism of the fuel filler flap sticks: pressing the button does not pop the flap, or only after tapping it. It appears between 60,000 and 100,000 km. The cause is a worn actuator or a corroded, frozen cable. In winter the cable can freeze, and the car cannot be refuelled.

What to check

  • Open and close the fuel flap several times: does it open without binding
  • Watch whether the flap has to be pressed or tapped to open
  • Look at the corrosion around the flap and the lock
1 more steps in the write-up

Weak heating: thermostat and a blocked cooling circuit

cheap repair

The heating warms up slowly or unevenly, and the temperature gauge behaves unusually. The cause is a stuck thermostat or old, deposit laden coolant. The water pump module often leaks as well.

What to check

  • After a cold start time how long it takes for the heating to warm up
  • Watch the temperature gauge in traffic and on the open road
  • Check the colour and level of the coolant in the expansion tank
1 more steps in the write-up

Checklist

Volkswagen Golf Sportsvan 1.4 TSI 125hp Comfortline

First what you would check on any car. Then the faults of this model.

Before you buy

Checklist

The printed sheet starts with what you would check on any car. What you tick stays on this device only.

On every car

Ask the owner

Faults of this model

vinkodex.com · Before you buy it, see what can go wrong.

Official recall1 recallsShow

The manufacturer fixes these for free at a franchised dealer. Ask with the VIN whether it was done.

A12/00787/24Safety recallInjuriesno date · EU Safety Gate

Cars initially used for internal purposes of Volkswagen AG might not have been correctly modified before they were sold to the general public. There is a possibility that certain safety systems of these cars are not correctly modified for street use. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

We could not check this: model year. The authority's notice

Engine and transmission

CZCA · 1.4 TFSI

92 kW (125 HP) · petrol

MQ200 · 5- or 6-speed manual

manual · 5–6 speed

Torque limit200 Nm
MakerVolkswagen

We built the code from the model and the gear count. The factory sheet does not state it.

Variant data

What is in this version

Factory data

Trim
Comfortline
Body
MPV
Fuel
petrol
Transmission
manual
Engine size
1395 cc
Power
92 kW (125 HP)
Drive
FWD
Production
2014–2018

Factory service interval

The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.

  • Air filter

    • 60,000 km or 4 years

  • Cabin (pollen) filter

    • 30,000 km or 2 years

  • Engine oil and oil filter

    • LongLife30,000 km or 2 years(valid only with LongLife-approved oil)
    • 15,000 km or 1 year

  • Brake fluid change

    • first: 3 years, then 2 years(first change at 3 years, then every two years)

  • Coolant (antifreeze) change

    • first: 193,000 km or 10 years, then 97,000 km or 5 years(G13 / G12++: first change at 120,000 miles or 10 years, then every 60,000 miles or 5 years)

  • Spark plugs, petrol

    • 60,000 km or 6 years
All I versions

Information, not an expert opinion

We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.

  • A fault on the list does not mean the car you are looking at has it.
  • A fault missing from the list does not mean the model is fault-free. Write-ups are made model by model. Not all of them are done.
  • You decide whether to buy. This is no substitute for an inspection. That needs a workshop and a history check.
Details in the terms