vinkodex.9 fault write-ups. 6 important. 7 recalls.
If you know the year, pick it. Faults for other years drop out of the list.
Before you buy
A thin wall of the mechatronics valve body can crack, which causes a loss of pressure. The typical signs: jerking and harsh shifting from 1st to 2nd at low speed, a flashing PRNDS display, then a gear engagement fault, intermittently at first.
What to check
In the EA211 the water pump and the thermostat are one plastic module, and the pump is driven not by the timing belt but by a separate toothed belt behind the exhaust camshaft. There are usually two problems with it: the plastic housing warps or cracks (slow coolant loss, a sweet smell, rising temperature), or the drive belt ages (a chirping noise, then an engine left with no cooling). The housing is particularly sensitive if oil reaches it: for example from a leaking crankcase ventilation. The module has to be replaced whole: dismantling it warps it in itself.
What to check
At the factory the roof drain hoses were fixed to their stubs with only a few spots of adhesive; heat separates them over time, and the water runs onto the headlining. The drains are also narrow and block up easily. The sign is a damp headlining around the A-pillar, or water in the footwell. The maker issued a technical bulletin about it for the 2015 to 2017 Golf and GTI models.
What to check
After startup or while driving a loud clicking, clattering noise comes from behind the dashboard, typically for three to five seconds, at irregular intervals. The actuator motors that move the climate control blend flaps fail. Stripping the dashboard is seven to eight hours of work, so the labour makes up most of the bill.
What to check
On a longer straight stretch, typically above 100 km/h, a small steering correction first has to overcome a noticeable force, and then the steering responds suddenly, with a jolt. It is most obvious when holding a lane: the car does not follow your hand smoothly but "jumps". It does not come from wear but is a characteristic of the steering rack, and VW issued a service bulletin (TPI) about replacing it. Outside warranty the replacement is a major item, comparable to a significant share of the car's value on an older example.
What to check
A milky, sometimes fingerprint like coating or mist appears on the inside of the xenon headlight lens, and the light output drops noticeably. It affects cars built up to mid 2016. VW issued a service bulletin (TPI) about it with a limit sample description, and replaced the affected lights under warranty. Outside warranty the replacement is charged per headlight unit.
What to check
The touchscreen of the head unit does not respond to touch, typically in the cold; meanwhile the radio changes station on its own, and the climate and navigation controls are unusable. It affects the Composition Media and Discover Media units between 2013 and 2016. A software update sometimes resolves it; if not, replacing the display unit is a substantial item.
What to check
The dash shows "Error: Workshop! Only leave vehicle in position P" with an audible warning. The message appears in whatever language the car is set to, for example "Fehler: Werkstatt! Fahrzeug nur in Stellung P verlassen" in German.
The message points at the gearbox, but the fault is not there. A tiny switch sits in the module under the selector lever and signals that the lever is in park (P). Its contact wears and can also burn. That makes the signal unreliable, and the car warns you. The fault codes appear as 617752, P173400 or B116229.
At first it is intermittent. Sometimes the message comes up, sometimes not, so a short test drive easily misses it. Later it becomes permanent, and the gearbox can drop into limp mode.
This fault looks more expensive than it is. The maker released a separate retrofit switch kit for it (5Q0713128A for the black module, 3Q0713128 for the white one), which can be fitted in half an hour. The kit costs 70 to 100 pounds. At a franchised dealer, however, the whole selector lever module sometimes gets replaced, which costs 626 to 1,000 pounds there. So the difference between the two routes is roughly tenfold.
The affected group is post 2013 MQB platform Volkswagen, Audi, Seat and Skoda cars with a DSG gearbox. The switch is in these gearboxes, because that is what these cars have in common. The part itself is not part of the gearbox but of the module under the lever.
What to check
The per cylinder ignition coil of these direct injection, turbocharged petrol engines fails. According to the Haynes service material this and similar simple electrical faults account for roughly eighty per cent of workshop visits.
In cold, damp weather, on startup, the engine runs unevenly, misfires under acceleration, and the engine warning light flashes or stays on. Do not keep driving with the light flashing: the unburnt fuel destroys the catalytic converter.
What to check
vinkodex.Checklist
First what you would check on any car. Then the faults of this model.
Before you buy
The printed sheet starts with what you would check on any car. What you tick stays on this device only.
The manufacturer fixes these for free at a franchised dealer. Ask with the VIN whether it was done.
Most recent: 13 May 2019
INFO/00145/21Safety recallInjuries13 May 2019 · EU Safety GateDefective material may be used in the rear suspension helical springs. As a result, the springs could break, impairing the driving stability and increasing the risk of an accident. The product does not comply with the requirements laid down in the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles
Remedy: Type of economic operator taking notified measure(s): Importer Category of measure(s): Recall of the product from end users Date of entry into force: 13/05/2019
18V464000STEERING:COLUMN LOCKING:ANTI-THEFT DEVICESTEERING:COLUMN LOCKING:ANTI-THEFT DEVICE11 July 2018 · NHTSA (USA)Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Risk: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
16V647000FUEL SYSTEM, GASOLINEFUEL SYSTEM, GASOLINE7 September 2016 · NHTSA (USA)Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Volkswagen Golf, Golf SportWagen, GTI, Audi A3 sedan and A3 Cabriolet vehicles. Due to a problem with the suction pump inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system.
Risk: As fuel accumulates in the EVAP system, it may leak out through the charcoal canister filter element. A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will replace the suction pump, free of charge. The recall began November 2016. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298, Audi owners may contact Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 20Y6 and 20Y5. This recall has been fully superseded by recall 24V-110.
15V229000FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMPFUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP17 April 2015 · NHTSA (USA)Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015 Volkswagen Golf, and GTI manufactured on February 17, 2014, to May 22, 2014, and Audi A3 manufactured on February 16, 2013, to April 23, 2014. Improper nickel plating of components within the fuel pump may result in the fuel pump failing.
Risk: If the fuel pump fails, the vehicle will not start, or if the engine is running, it will stop and the vehicle will stall, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect the vehicles and replace any affected fuel pumps, free of charge. The recall began on June 16, 2015. Owners may contact Volkswagen at 1-800-893-5298 or Audi at 1-800-253-2834.
14V412000STEERINGSTEERING7 July 2014 · NHTSA (USA)Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015 Golf and GTI vehicles manufactured January 27, 2014, to May 12, 2014. In the affected vehicles, the stabilizer link fasteners may come loose and possibly interfere with the steering of the vehicle.
Risk: A loose stabilizer link may interfere with the vehicle's steering, requiring additional effort to control the vehicle, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the front stabilizer links, free of charge. The recall began in July 2014. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 40K9/1W.
A12/00787/24Safety recallInjuriesno date · EU Safety GateCars initially used for internal purposes of Volkswagen AG might not have been correctly modified before they were sold to the general public. There is a possibility that certain safety systems of these cars are not correctly modified for street use. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown
A12/1253/19Safety recallInjuriesno date · EU Safety GateThe belt pulley of the cam gear could break and the screws on the camshaft adjuster may loosen. As a result, engine oil can leak onto the road, posing a risk to the following traffic.
Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown
CHZD · 1.0 TFSI85 kW (116 HP) · petrol
DQ200 · 7-speed DSG, dry clutchDSG · 7 speed
We built the code from the model and the gear count. The factory sheet does not state it. More than one engine code is possible. The fault list shows the faults of each.
Variant data
The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.
Air filter
DQ200: lifetime fill by the maker, not in practice
Cabin (pollen) filter
Engine oil and oil filter
Brake fluid change
Coolant (antifreeze) change
Spark plugs, petrol
We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.