vinkodex.

Opel Insignia 1.5 Turbo 140hp Ecotec Business Ex. common faults.

2017–2020, hatchback, petrol, 140 HP.

The list covers this version.

What you save stays on this device only. My saves

1 fault write-ups. Important. 4 recalls.

If you know the year, pick it. Faults for other years drop out of the list.

Before you buy

Known faults

1 important faults

Insignia: plastic thermostat housing and water pump

expensive

The shared weak point of the Insignia A and B is the cooling circuit: the thermostat housing and some of the pipes are plastic, which can crack under heat cycling. The consequence: coolant loss, a risk of overheating, and a fault code on coolant temperature.

Show the rest

At higher mileage the water pump shows bearing damage: a wet drip trail, running noise. If the coolant runs out, the engine can overheat and be damaged. Replacing the water pump prevents that.

between 80,000 and 180,000 km

What to check

  • Check the level and colour of the coolant in the expansion tank: frequent topping up is suspect
  • Cold and warm, look for damp around the plastic thermostat housing and the connections
  • Listen for noise from the water pump when warm
2 more steps in the write-up

Checklist

Opel Insignia 1.5 Turbo 140hp Ecotec Business Ex.

First what you would check on any car. Then the faults of this model.

Before you buy

Checklist

The printed sheet starts with what you would check on any car. What you tick stays on this device only.

On every car

Ask the owner

Faults of this model

vinkodex.com · Before you buy it, see what can go wrong.

Official recall4 recallsShow

The manufacturer fixes these for free at a franchised dealer. Ask with the VIN whether it was done.

A12/00135/21Safety recallInjuriesno date · EU Safety Gate

The wheel screws are not tightened with the required torque. This could lead to a wheel being lost during driving, increasing the risk of an accident.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/00349/20Safety recallFire, Injuriesno date · EU Safety Gate

Engine oil from a crack-prone oil return pipe may come into contact with hot exhaust parts and cause a fire. Oil might also leak onto the road.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/1889/19Safety recallInjuriesno date · EU Safety Gate

As a result of a production error, the crossmember of the front seat structure has been welded incorrectly. This could lead to the seat not having the required crash behaviour in the event of an accident, increasing the risk of an injury.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/1891/19Safety recallInjuriesno date · EU Safety Gate

Defective production of the wheel rims may result in reduced wall thickness and subsequent cracks. This may lead to loss of control over the vehicle increasing the risk of an accident.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

Engine and transmission

No engine and transmission for this yet. When they are in, you see them here.

Variant data

What is in this version

Factory data

Trim
Ecotec Business Ex.
Body
hatchback
Fuel
petrol
Transmission
manual
Engine size
1490 cc
Power
104 kW (141 HP)
Drive
FWD
Production
2017–2020

Factory service interval

The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.

  • Air filter

    • 60,000 km or 4 years

  • Cabin (pollen) filter

    • 30,000 km or 2 years

  • Brake fluid change

    • first: 3 years, then 2 years(first change at 3 years, then every two years)
All B versions

Information, not an expert opinion

We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.

  • A fault on the list does not mean the car you are looking at has it.
  • A fault missing from the list does not mean the model is fault-free. Write-ups are made model by model. Not all of them are done.
  • You decide whether to buy. This is no substitute for an inspection. That needs a workshop and a history check.
Details in the terms