vinkodex.

Volkswagen Passat 1.4 TSI BMT High Executive Edition common faults.

2010–2014, saloon, petrol, 122 HP.

The fault list covers: CAXA engine, DQ200 transmission.

What you save stays on this device only. My saves

6 fault write-ups. 4 important. 9 recalls.

If you know the year, pick it. Faults for other years drop out of the list.

Before you buy

Known faults

4 important faults

critical1

1.2 / 1.4 TSI (EA111): timing chain and chain tensioner

critical

A few seconds of chain rattle on a cold start, later a permanent noise; the chain stretches and the tensioner does not hold it. If the chain jumps, the engine is badly damaged inside, and the repair is a rebuild. The tensioner is driven by oil pressure, so it does not hold with the engine stopped: a car left rolling in gear is the typical trigger for the chain jumping.

between 65,000 and 100,000 km

What to check

  • Start it cold, and in the first 2 to 3 seconds watch for the rattle from the chain side
  • Ask whether the chain and the tensioner have been replaced, and ask for the invoice
  • Check the oil change history in the service book: stretched intervals speed up the wear
1 more steps in the write-up

expensive3

B6 / B7: electric parking brake seizing

expensive

The servo motor of the electric parking brake seizes: the brake does not release, or does not apply properly. The repair is replacing the motor or the switch, and the rear caliper can be affected too. On a used car it is a separate warning sign if the seller blames only the switch.

What to check

  • Apply and release the electric parking brake five or six times in a row
  • Watch whether it releases evenly and without noise on both sides
  • Try it on a slope: does it really hold the car
1 more steps in the write-up

B7: wishbones and leaking dampers

expensive

The front wishbones and the dampers wear far earlier than average: in the roadworthiness test the suspension failure rate on the B7 stands out, and the leaking damper appears primarily on this generation too; after seven years the figures go clearly above average. Symptoms: uneven tyre wear, vibration through the steering wheel, knocking on uneven roads, and visible oily dampness on the damper rod. Per side the wishbone is a mid range parts and labour job, and the damper costs less; when they come due together the total is a serious item.

What to check

  • Look at the inner and outer edges of the tyres: uneven wear indicates a suspension fault
  • On an uneven road with the window open, listen for knocking from the front wheels
  • Shine a light on the damper rod: oily, dusty dampness means a leak
2 more steps in the write-up

DQ200 (7 speed dry DSG): mechatronics

expensive

A thin wall of the mechatronics valve body can crack, which causes a loss of pressure. The typical signs: jerking and harsh shifting from 1st to 2nd at low speed, a flashing PRNDS display, then a gear engagement fault, intermittently at first.

What to check

  • Pull away slowly from standstill and watch the 1 to 2 shift: does it jerk, is it harsh
  • Check whether the PRNDS display flashes or the dash reports a gearbox fault
  • In creep mode (brake released), does the car move off evenly
1 more steps in the write-up

comfort1

B6 / B7: electrical fault in the door lock module

comfort

The contacts of the lock module cannot take the current draw of the lock motor, so over time they burn through and their resistance rises. At first the door only sometimes fails to open or lock centrally, later not at all. The alarm often reports it too: the car sees a closed door as open. Typical fault codes are 67074 (central locking motors, electrical fault) and 67330.

What to check

  • Lock and unlock centrally ten times in a row, watching all four doors
  • Check on the dash whether it reports an open door while closed
  • Try it when cold too: at first the fault only appears at low temperature
2 more steps in the write-up

cheap repair1

DSG selector lever: failure of the P position switch

cheap repair

The dash shows "Error: Workshop! Only leave vehicle in position P" with an audible warning. The message appears in whatever language the car is set to, for example "Fehler: Werkstatt! Fahrzeug nur in Stellung P verlassen" in German.

Show the rest

The message points at the gearbox, but the fault is not there. A tiny switch sits in the module under the selector lever and signals that the lever is in park (P). Its contact wears and can also burn. That makes the signal unreliable, and the car warns you. The fault codes appear as 617752, P173400 or B116229.

At first it is intermittent. Sometimes the message comes up, sometimes not, so a short test drive easily misses it. Later it becomes permanent, and the gearbox can drop into limp mode.

This fault looks more expensive than it is. The maker released a separate retrofit switch kit for it (5Q0713128A for the black module, 3Q0713128 for the white one), which can be fitted in half an hour. The kit costs 70 to 100 pounds. At a franchised dealer, however, the whole selector lever module sometimes gets replaced, which costs 626 to 1,000 pounds there. So the difference between the two routes is roughly tenfold.

The affected group is post 2013 MQB platform Volkswagen, Audi, Seat and Skoda cars with a DSG gearbox. The switch is in these gearboxes, because that is what these cars have in common. The part itself is not part of the gearbox but of the module under the lever.

What to check

  • Watch the dash after starting: the message is intermittent and can be missed on a short loop
  • Move the lever from P to D and back several times, then get out and lock the car
  • Ask whether the selector lever switch has been replaced already, and ask for the invoice
2 more steps in the write-up

Checklist

Volkswagen Passat 1.4 TSI BMT High Executive Edition

First what you would check on any car. Then the faults of this model.

Before you buy

Checklist

The printed sheet starts with what you would check on any car. What you tick stays on this device only.

On every car

Ask the owner

Faults of this model

vinkodex.com · Before you buy it, see what can go wrong.

Official recall9 recallsShow

The manufacturer fixes these for free at a franchised dealer. Ask with the VIN whether it was done.

Most recent: 30 October 2024

24V834000AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULEAIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE30 October 2024 · NHTSA (USA)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2019 Beetle, Beetle Convertible, 2012-2014 Passat, 2017 Passat Wagon, and 2006-2007 Passat Sedan vehicles. The driver's side frontal air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Dealers will replace the driver's side front air bag module, free of charge. Owner notification letters were mailed December 4, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 69EG, 69GQ, and 69E6.

The authority's notice

19V862000AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULEAIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE4 December 2019 · NHTSA (USA)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2015 Passat, 2011-2014 Golf A6, and 2011-2013 Audi A3 diesel vehicles, thought to have been previously repaired under one of the Takata air bag recalls. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Volkswagen will notify owners, and dealers will replace the driver's side air bag inflators, free of charge. The recall began December 20, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 69R6, 69Q8, 69Q9, and 69Y5.

The authority's notice

19V389000EXTERIOR LIGHTING:HEADLIGHTSEXTERIOR LIGHTING:HEADLIGHTS22 May 2019 · NHTSA (USA)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2020 Volkswagen Passat and 2018-2019 Atlas vehicles. The blocking cap disabling the adjustment of the headlight's horizontal aim may not have been installed. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk: Without the blocking cap, the headlight aim can be adjusted out of specification, reducing visibility and increasing the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will inspect and, as necessary, block the headlight horizontal adjustment, free of charge. The recall began July 16, 2019. Owners may contact Volkswagen customer service at 1-800-253-2834. Volkswagen's number for this recall is 94L9.

The authority's notice

18V148000AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULEAIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE6 March 2018 · NHTSA (USA)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2009-2014 Volkswagen CC, 2010-2014 Golf, 2010-2014 Eos, 2007-2010 Passat Sedan and Wagon, and 2012-2014 Passat vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.

Risk: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator with an alternative inflator, free of charge. The recall began March 16, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69Q9. Note: This recall partially supersedes recall 16V-078.

The authority's notice

17V309000ENGINE AND ENGINE COOLING:ENGINE:DIESELENGINE AND ENGINE COOLING:ENGINE:DIESEL11 May 2017 · NHTSA (USA)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2014 Passat vehicles, equipped with diesel engines and Direct-Shift Transmissions (DSG). The vehicle's underbody heat shield may not be long enough to protect the right half-shaft grease boot from heat, potentially resulting in a grease leak.

Risk: If the leaking grease contacts a heated surface, such as the exhaust system and/or the diesel particulate filter (DPF), it could increase the risk of fire.

Remedy: Volkswagen will notify owners, and dealers will replace the driveshaft heat shield, free of charge. The recall began on July 7, 2017. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 23W5.

The authority's notice

16V171000ELECTRICAL SYSTEM:WIRINGELECTRICAL SYSTEM:WIRING24 March 2016 · NHTSA (USA)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2012-2014 Passat vehicles equipped with TDI engines. Due to improperly assembled wire seals in a connector for an underbody sensor, water may enter and corrode the electrical connectors of the sensor, causing an electrical short.

Risk: An electrical short can cause the electrical connectors of the sensor to overheat, increasing the risk of a fire.

Remedy: Volkswagen will notify owners, and dealers will inspect the connector, replacing it as necessary, free of charge. The recall began in September. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 23T3.

The authority's notice

16V078000AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULEAIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE10 February 2016 · NHTSA (USA)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2010-2014 Golf, 2007-2010 Passat sedans and wagon, 2012-2014 Passat sedan and Eos, 2009-2014 CC, 2009-2012 Audi Q5, 2010-2012 S5 Cabriolet and 2010-2012 Audi A5 Cabriolet vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to rupture.

Risk: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflators, free of charge. Volkswagen issued an interim notification to owners on April 12, 2016, and will send a second notification when parts are available. Volkswagen will notify owners again once parts are available. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298. Audi owners may contact Audi customer service at 1-800-253-2834.

The authority's notice

14V125000EXTERIOR LIGHTING:HEADLIGHTSEXTERIOR LIGHTING:HEADLIGHTS17 March 2014 · NHTSA (USA)

Volkswagen Group of America (Volkswagen) is recalling certain model year 2012-2013 Passat vehicles manufactured January 2011 through November 2012. In the affected vehicles, the low beam headlight bulb may become loose and lose electrical contact.

Risk: A loss of low beam headlights may reduce the driver's visibility and increase the risk of a crash.

Remedy: Volkswagen notified owners, and dealers will replace the bulb holder, free of charge. The recall began in May 2014. Owners may contact Volkswagen at 1-800-822-8987. Volkswagens recall number associated with this campaign is 94G8/7V.

The authority's notice

12V146000FUEL SYSTEM, DIESELFUEL SYSTEM, DIESEL5 April 2012 · NHTSA (USA)

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2012 PASSAT VEHICLES, MANUFACTURED FROM JANUARY 18, 2011, THROUGH JUNE 1, 2011. DURING ASSEMBLY, THESE VEHICLES WERE BUILT WITH A DIESEL FUEL FILTER ELEMENT THAT MAY NOT SEAL CORRECTLY.

Risk: OVER TIME, OR AFTER CERTAIN DRIVING DISTANCES, THESE VEHICLES ARE SUSCEPTIBLE TO FUEL LEAKAGE. LEAKING FUEL, IN THE PRESENCE OF AN IGNITION SOURCE, MAY LEAD TO A FIRE.

Remedy: VOLKSWAGEN WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE DIESEL FUEL FILTER ELEMENTS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 27, 2012. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

The authority's notice

Engine and transmission

CAXA · 1.4 TFSI

90 kW (122 HP) · petrol

DQ200 · 7-speed DSG, dry clutch

DSG · 7 speed

Clutchdry
Torque limit250 Nm
MakerVolkswagen

We built the code from the model and the gear count. The factory sheet does not state it.

Variant data

What is in this version

Factory data

Trim
BMT High Executive Edition
Body
saloon
Fuel
petrol
Transmission
automatic
Engine size
1390 cc
Power
90 kW (122 HP)
Drive
FWD
Production
2010–2014

Factory service interval

The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.

  • Air filter

    • 60,000 km or 4 years

  • DQ200: lifetime fill by the maker, not in practice

    • lifetime fill: the maker does NOT specify a change

  • Cabin (pollen) filter

    • 30,000 km or 2 years

  • Engine oil and oil filter

    • LongLife30,000 km or 2 years(valid only with LongLife-approved oil)
    • 15,000 km or 1 year

  • Brake fluid change

    • first: 3 years, then 2 years(first change at 3 years, then every two years)

  • Coolant (antifreeze) change

    • first: 193,000 km or 10 years, then 97,000 km or 5 years(G13 / G12++: first change at 120,000 miles or 10 years, then every 60,000 miles or 5 years)

  • Spark plugs, petrol

    • 60,000 km or 6 years
All B7 versions

Information, not an expert opinion

We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.

  • A fault on the list does not mean the car you are looking at has it.
  • A fault missing from the list does not mean the model is fault-free. Write-ups are made model by model. Not all of them are done.
  • You decide whether to buy. This is no substitute for an inspection. That needs a workshop and a history check.
Details in the terms