vinkodex.

Volkswagen Passat 1.4 TSI 125hp Highline common faults.

2014–2019, estate, petrol, 125 HP.

The fault list covers: CZCA engine, MQ250 transmission.

What you save stays on this device only. My saves

4 fault write-ups. 2 important. 7 recalls.

If you know the year, pick it. Faults for other years drop out of the list.

Before you buy

Known faults

2 important faults

expensive2

MQ200 / MQ250 manual gearbox: differential bearing and synchros

expensive

The light, magnesium cased MQ200 and the MQ250, sized for higher torque, are the most widespread manual gearboxes in the transverse engine VAG models. Both have the same two weak points, and both depend on use.

Show the rest

The first is the differential bearing: as it wears you first get a droning, then a whine from the thrust bearings of the output shaft. Left alone, the planetary shaft can fail and in extreme cases punch through the gearbox casing: from then on it is not a repair but a replacement.

The second is the synchros: they can start crunching at around 50,000 km with aggressive driving. This type does not like dumping the clutch or slipping it, and on a used car that is exactly what you have to listen for.

above 50,000 km

What to check

  • On the test drive with the window down, listen to the gearbox both off and on the throttle: droning or whining is suspect
  • Shift up and down quickly, especially into 2nd and 3rd: crunching means synchro wear
  • Try engaging 1st and reverse when cold: resistance here means wear
2 more steps in the write-up

EA211 (1.0 to 1.5 TSI): water pump and thermostat module leak

expensive

In the EA211 the water pump and the thermostat are one plastic module, and the pump is driven not by the timing belt but by a separate toothed belt behind the exhaust camshaft. There are usually two problems with it: the plastic housing warps or cracks (slow coolant loss, a sweet smell, rising temperature), or the drive belt ages (a chirping noise, then an engine left with no cooling). The housing is particularly sensitive if oil reaches it: for example from a leaking crankcase ventilation. The module has to be replaced whole: dismantling it warps it in itself.

What to check

  • Check the level in the expansion tank, and ask whether it needs topping up
  • After a cold start smell the engine bay: a sweet smell means coolant
  • Look for dried, whitish pink deposits on the exhaust side of the cylinder head
2 more steps in the write-up

comfort2

B8 Variant: powered tailgate

comfort

The powered tailgate of the estate is a common complaint: the lifting motors, the microswitches and the closing mechanism can all fail. The tailgate stops halfway, does not close properly, or opens again on its own.

What to check

  • Open and close the powered tailgate five times in a row
  • Watch whether it stops halfway or opens again
  • Try it from the key and with the gesture under the bumper too, if fitted
1 more steps in the write-up

B8: infotainment freezing and Bluetooth dropouts

comfort

The head unit freezes, restarts, or shuts down entirely; the Bluetooth connection drops regularly, and the wireless charger does not recognise the phone. It happens as early as 10,000 to 30,000 km. It is often software, but a hardware fault can be behind it too: the slow response of the navigation and the outdated map are part of the same thing. Cars built up to 2016 still have the first generation (MIB1) head unit, and most of the faults fall on the 2014 to 2016 model years. Intermittent loss of the reversing camera belongs to the same group.

What to check

  • Cycle the ignition three times and check whether the screen comes up every time
  • Pair a phone over Bluetooth and leave it connected for ten minutes during a test drive
  • Try the wireless charger if fitted: does it recognise the phone
2 more steps in the write-up

Checklist

Volkswagen Passat 1.4 TSI 125hp Highline

First what you would check on any car. Then the faults of this model.

Before you buy

Checklist

The printed sheet starts with what you would check on any car. What you tick stays on this device only.

On every car

Ask the owner

Faults of this model

vinkodex.com · Before you buy it, see what can go wrong.

Official recall7 recallsShow

The manufacturer fixes these for free at a franchised dealer. Ask with the VIN whether it was done.

Most recent: 16 September 2020

20V561000UNKNOWN OR OTHERUNKNOWN OR OTHER16 September 2020 · NHTSA (USA)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Golf R and Atlas, 2017 Golf Alltrack and E-Golf and 2016-2018 Passat vehicles. These internal use vehicles were sold without confirmation that they were built to all applicable regulatory requirements and may have been modified prior to sale. As such, these vehicles may fail to comply with the requirements of various Federal Motor Vehicle Safety Standards.

Risk: Vehicles that do not meet all regulatory requirements may have an increased risk of a crash or injury to vehicle occupants.

Remedy: Volkswagen will notify owners and will repurchase the vehicles. The recall began October 6, 2020. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01E9.

The authority's notice

19V389000EXTERIOR LIGHTING:HEADLIGHTSEXTERIOR LIGHTING:HEADLIGHTS22 May 2019 · NHTSA (USA)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2020 Volkswagen Passat and 2018-2019 Atlas vehicles. The blocking cap disabling the adjustment of the headlight's horizontal aim may not have been installed. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk: Without the blocking cap, the headlight aim can be adjusted out of specification, reducing visibility and increasing the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will inspect and, as necessary, block the headlight horizontal adjustment, free of charge. The recall began July 16, 2019. Owners may contact Volkswagen customer service at 1-800-253-2834. Volkswagen's number for this recall is 94L9.

The authority's notice

16V403000FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAILFUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL6 June 2016 · NHTSA (USA)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2016 Jetta vehicles manufactured October 31, 2015, to January 21, 2016, 2016 Passat vehicles, equipped with 1.8T engines manufactured November 13, 2015, to December 9, 2015, and 2016 Golf vehicles manufactured November 5, 2015, to November 11, 2015. In the affected vehicles, the fuel rail may detach from the cylinder head and result in a fuel leak.

Risk: A fuel leak, in the presence of an ignition source, can result in a vehicle fire.

Remedy: Volkswagen will notify owners, and dealers will replace the cylinder heads, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 15F7.

The authority's notice

15V705000ENGINE AND ENGINE COOLING:ENGINEENGINE AND ENGINE COOLING:ENGINE26 October 2015 · NHTSA (USA)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Jetta, Beetle, Beetle Convertible, Passat, Golf and Golf SportWagen vehicles. In the affected vehicles, the camshaft lobe that drives the brake vacuum pump may shear off, resulting in a loss of brake assist.

Risk: If the camshaft lobe shears off there would be a loss of brake assist, lengthening the distance needed to stop the vehicle and increasing the risk of a crash.

Remedy: Volkswagen dealer will update the engine control module (ECM) software. The recall began March 2016. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 23R1.

The authority's notice

A12/00793/24Safety recallInjuriesno date · EU Safety Gate

Cars initially used for internal purposes of Volkswagen AG might not have been correctly modified before they were sold to the general public. There is a possibility that certain safety systems of these cars are not correctly modified for street use. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/0256/17Safety recallInjuriesno date · EU Safety Gate

It is possible that the wheel bolts were not tightened with the correct torque which could result in the loss of the wheel. Also, the running direction of the tyres may not have been taken into account when the winter tyres were fitted which could have a negative effect on driving stability.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/0387/17Safety recallInjuriesno date · EU Safety Gate

Some vehicles have differences in the mixture ratio for the initiating device, which could lead to the driver and passenger airbag or seat-belt pre-tensioner not activating in the event of an accident.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

Engine and transmission

CZCA · 1.4 TFSI

92 kW (125 HP) · petrol

MQ250 · 5- or 6-speed manual

manual · 5–6 speed

Torque limit250 Nm
MakerVolkswagen

We built the code from the model and the gear count. The factory sheet does not state it.

Variant data

What is in this version

Factory data

Trim
Highline
Body
estate
Fuel
petrol
Transmission
manual
Engine size
1395 cc
Power
92 kW (125 HP)
Drive
FWD
Production
2014–2019

Factory service interval

The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.

  • Air filter

    • 60,000 km or 4 years

  • Cabin (pollen) filter

    • 30,000 km or 2 years

  • Engine oil and oil filter

    • LongLife30,000 km or 2 years(valid only with LongLife-approved oil)
    • 15,000 km or 1 year

  • Brake fluid change

    • first: 3 years, then 2 years(first change at 3 years, then every two years)

  • Coolant (antifreeze) change

    • first: 193,000 km or 10 years, then 97,000 km or 5 years(G13 / G12++: first change at 120,000 miles or 10 years, then every 60,000 miles or 5 years)

  • Spark plugs, petrol

    • 60,000 km or 6 years
All B8 versions

Information, not an expert opinion

We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.

  • A fault on the list does not mean the car you are looking at has it.
  • A fault missing from the list does not mean the model is fault-free. Write-ups are made model by model. Not all of them are done.
  • You decide whether to buy. This is no substitute for an inspection. That needs a workshop and a history check.
Details in the terms