vinkodex.5 fault write-ups. 2 important. 7 recalls.
If you know the year, pick it. Faults for other years drop out of the list.
Before you buy
A thin wall of the mechatronics valve body can crack, which causes a loss of pressure. The typical signs: jerking and harsh shifting from 1st to 2nd at low speed, a flashing PRNDS display, then a gear engagement fault, intermittently at first.
What to check
In the EA211 the water pump and the thermostat are one plastic module, and the pump is driven not by the timing belt but by a separate toothed belt behind the exhaust camshaft. There are usually two problems with it: the plastic housing warps or cracks (slow coolant loss, a sweet smell, rising temperature), or the drive belt ages (a chirping noise, then an engine left with no cooling). The housing is particularly sensitive if oil reaches it: for example from a leaking crankcase ventilation. The module has to be replaced whole: dismantling it warps it in itself.
What to check
The powered tailgate of the estate is a common complaint: the lifting motors, the microswitches and the closing mechanism can all fail. The tailgate stops halfway, does not close properly, or opens again on its own.
What to check
The head unit freezes, restarts, or shuts down entirely; the Bluetooth connection drops regularly, and the wireless charger does not recognise the phone. It happens as early as 10,000 to 30,000 km. It is often software, but a hardware fault can be behind it too: the slow response of the navigation and the outdated map are part of the same thing. Cars built up to 2016 still have the first generation (MIB1) head unit, and most of the faults fall on the 2014 to 2016 model years. Intermittent loss of the reversing camera belongs to the same group.
What to check
The dash shows "Error: Workshop! Only leave vehicle in position P" with an audible warning. The message appears in whatever language the car is set to, for example "Fehler: Werkstatt! Fahrzeug nur in Stellung P verlassen" in German.
The message points at the gearbox, but the fault is not there. A tiny switch sits in the module under the selector lever and signals that the lever is in park (P). Its contact wears and can also burn. That makes the signal unreliable, and the car warns you. The fault codes appear as 617752, P173400 or B116229.
At first it is intermittent. Sometimes the message comes up, sometimes not, so a short test drive easily misses it. Later it becomes permanent, and the gearbox can drop into limp mode.
This fault looks more expensive than it is. The maker released a separate retrofit switch kit for it (5Q0713128A for the black module, 3Q0713128 for the white one), which can be fitted in half an hour. The kit costs 70 to 100 pounds. At a franchised dealer, however, the whole selector lever module sometimes gets replaced, which costs 626 to 1,000 pounds there. So the difference between the two routes is roughly tenfold.
The affected group is post 2013 MQB platform Volkswagen, Audi, Seat and Skoda cars with a DSG gearbox. The switch is in these gearboxes, because that is what these cars have in common. The part itself is not part of the gearbox but of the module under the lever.
What to check
vinkodex.Checklist
First what you would check on any car. Then the faults of this model.
Before you buy
The printed sheet starts with what you would check on any car. What you tick stays on this device only.
The manufacturer fixes these for free at a franchised dealer. Ask with the VIN whether it was done.
Most recent: 4 December 2019
19V862000AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULEAIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE4 December 2019 · NHTSA (USA)Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2015 Passat, 2011-2014 Golf A6, and 2011-2013 Audi A3 diesel vehicles, thought to have been previously repaired under one of the Takata air bag recalls. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's side air bag inflators, free of charge. The recall began December 20, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 69R6, 69Q8, 69Q9, and 69Y5.
19V389000EXTERIOR LIGHTING:HEADLIGHTSEXTERIOR LIGHTING:HEADLIGHTS22 May 2019 · NHTSA (USA)Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2020 Volkswagen Passat and 2018-2019 Atlas vehicles. The blocking cap disabling the adjustment of the headlight's horizontal aim may not have been installed. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Risk: Without the blocking cap, the headlight aim can be adjusted out of specification, reducing visibility and increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect and, as necessary, block the headlight horizontal adjustment, free of charge. The recall began July 16, 2019. Owners may contact Volkswagen customer service at 1-800-253-2834. Volkswagen's number for this recall is 94L9.
19V014000AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULEAIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE11 January 2019 · NHTSA (USA)Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015 Passat, 2015-2016 Eos, 2015-2017 CC, 2016-2017 TT Roadster, TT Coupe, 2017 Audi R8 Coupe, and R8 Spyder vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Risk: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator with an alternative inflator, free of charge. The recall began March 4, 2019. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298; Audi owners may contact Audi at 1-800-253-2834. Volkswagen's number for this recall is 69S8 (Audi) and 69Y5 (Volkswagen).
15V705000ENGINE AND ENGINE COOLING:ENGINEENGINE AND ENGINE COOLING:ENGINE26 October 2015 · NHTSA (USA)Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Jetta, Beetle, Beetle Convertible, Passat, Golf and Golf SportWagen vehicles. In the affected vehicles, the camshaft lobe that drives the brake vacuum pump may shear off, resulting in a loss of brake assist.
Risk: If the camshaft lobe shears off there would be a loss of brake assist, lengthening the distance needed to stop the vehicle and increasing the risk of a crash.
Remedy: Volkswagen dealer will update the engine control module (ECM) software. The recall began March 2016. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 23R1.
15V373000SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGSSERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS15 June 2015 · NHTSA (USA)Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015 Passat vehicles manufactured May 18, 2015, to May 21, 2015. The affected vehicles have a brake line at the left rear wheel area that may not have been properly tightened.
Risk: If the brake line was not properly tightened, it may leak brake fluid, causing a reduction in braking performance, lengthening the distance needed to stop the vehicle and increasing the risk of crash.
Remedy: Volkswagen has notified owners, and dealers will tighten the brake line fitting, free of charge. The recall began on June 11, 2015. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 47M3.
15V028000FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAILFUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL23 January 2015 · NHTSA (USA)Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2014-2015 Jetta vehicles manufactured March 28, 2014, to November 24, 2014, 2014-2015 Passat vehicles manufactured April 7, 2014, to November 18, 2014, 2015 Golf and GTI vehicles manufactured July 1, 2014, to November 20, 2014, and 2014-2015 Beetle and Beetle Convertible vehicles manufactured March 31, 2014, to November 27, 2014. A sealing cap at the fuel rail may fail, allowing fuel to leak into the engine compartment.
Risk: A fuel leak, in the presence of an ignition source, can result in a vehicle fire.
Remedy: Volkswagen will notify owners, and dealers will replace the fuel rails with new parts, free of charge. The recall began February 6, 2015. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 24BL. Note: This recall expands and supersedes recall 14V-809 (Volkswagen recall number 24Bi) and only affects vehicles not previously repaired under that campaign.
14V670000SEATSSEATS24 October 2014 · NHTSA (USA)Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015 Volkswagen Jetta and Passat vehicles manufactured September 23, 2014, to October 9, 2014, and equipped with manual front seatback recliners. In the affected vehicles, the seatback recliner retaining bracket may not engage correctly, resulting in unexpected movement of the seatback.
Risk: Unexpected movement of the driver's seatback may distract the driver, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect the assembly of the seatback recliner retaining bracket, correcting it as necessary, free of charge. The recall began in October 2014. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 72F1.
Variant data
The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.
Air filter
DQ200: lifetime fill by the maker, not in practice
Cabin (pollen) filter
Engine oil and oil filter
Brake fluid change
Coolant (antifreeze) change
Spark plugs, petrol
We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.