vinkodex.

Volkswagen Polo 1.4 16V 75hp Athene common faults.

2001–2005, hatchback, petrol, 75 HP.

The fault list covers: AUA, BBY, BKY engine.

What you save stays on this device only. My saves

5 fault write-ups. 1 important. 2 recalls.

If you know the year, pick it. Faults for other years drop out of the list.

Before you buy

Known faults

1 important faults

expensive1

Electric power steering failure

expensive

The electric assistance drops out: the steering suddenly goes heavy, typically while driving or when manoeuvring, and the power steering warning appears on the dash. Sometimes it is only intermittent, more often when cold. The fault is in the unit built into the steering column; the replacement is expensive relative to the value of a Polo. A refurbished unit can be fitted, but it needs coding.

What to check

  • Turn the wheel lock to lock with the engine off and then running: the assistance has to be even throughout
  • Watch the dash on startup: the power steering light must go out
  • Try it immediately after a cold start, when the fault is more common
2 more steps in the write-up

comfort4

Coolant temperature sensor (G62) failure

comfort

The G62 sensor tells the engine control unit how hot the coolant is. If it is faulty, the control unit thinks a warm engine is cold, and runs it rich: hard warm or cold starting, a rough idle, markedly increased fuel consumption, and a dash temperature gauge that jumps around or never reaches its usual reading. The part is cheap and can be replaced in half an hour: the trouble is that many people do not recognise it and replace an injector or a lambda sensor instead. If the fault persists, the rich mixture can destroy the catalytic converter too.

What to check

  • Warm it up and watch the dash temperature gauge: the needle should sit steadily at the middle reading, not jump around
  • Watch a cold start, then a warm start after twenty minutes standing
  • With a code reader look for the 17664 / P1256 code in the engine control unit
2 more steps in the write-up

IV: front control arm wear (before the 2008 facelift)

comfort

The front control arms of the pre 2008 Polo IV wear out quickly: knocking on uneven roads, uneven tyre wear, vague steering. The 9N3 built from 2008 already got the successor front suspension design, where the phenomenon is rarer. Per side it is a moderate parts and labour job, but it rarely stops at one side.

What to check

  • Check the build year on the B-pillar sticker: the pre 2008 cars are the affected ones
  • On an uneven road with the window open, listen for knocking from the front
  • Look at the inner and outer edges of the tyres: uneven wear indicates a suspension fault
1 more steps in the write-up

Rear drum brake seizing

comfort

The wheel cylinder and the shoe mechanism of the rear drum brake rust up, and the brake drags or seizes completely. The symptoms are a rear wheel heating up, pulling, weakening braking, and insufficient brake force on one side at the roadworthiness test. On a car that is used little and stands a lot it rusts sooner.

What to check

  • After a short test drive, carefully feel the rear wheels: one side being hotter is suspect
  • Apply and release the handbrake several times: it must move without binding
  • Push the car by hand on the level: noticeable resistance indicates a seized brake
1 more steps in the write-up

Secondary air system: pump and combination valve (P0411)

comfort

From the late nineties to around 2006, petrol engines used a secondary air pump to blow fresh air into the exhaust on a cold start, so the catalytic converter reaches operating temperature faster. The impeller of the pump rusts or its bearing seizes, soot clogs the combination valve (N112), and the rubber hoses crack. The control unit then stores the `P0411` code. It barely affects driving, but the engine warning light is on, and the emissions test can fail because of it, and the roadworthiness test with it.

What to check

  • After a cold start watch for 30 to 60 seconds: can you hear the pump droning from the engine bay
  • Check whether the engine warning light is on, and have it read out: P0411 (VAG code 16795) points to this system
  • Ask when the last emissions test was, and whether it passed first time
2 more steps in the write-up

Checklist

Volkswagen Polo 1.4 16V 75hp Athene

First what you would check on any car. Then the faults of this model.

Before you buy

Checklist

The printed sheet starts with what you would check on any car. What you tick stays on this device only.

On every car

Ask the owner

Faults of this model

vinkodex.com · Before you buy it, see what can go wrong.

Official recall2 recallsShow

The manufacturer fixes these for free at a franchised dealer. Ask with the VIN whether it was done.

A12/01485/22Safety recallInjuriesno date · EU Safety Gate

The airbag propellant may deteriorate over time. In the event of an accident this can lead to the release of fragments of the front airbag from the generator housing, increasing the risk of injury. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

A12/01892/20Safety recallInjuriesno date · EU Safety Gate

The vehicles affected may have been fitted with Takata gas generators which could allow the ingress of moisture and thus result in the degradation of the propellant. If the airbag deploys, this could cause the gas generator to burst, causing metal parts to enter the vehicle's interior, causing injuries to the occupants of the vehicle.

Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown

The authority's notice

Engine and transmission

3 engines · 0 transmissions

AUA · 1.4

55 kW (75 HP) · petrol

We built the code from the model and the gear count. The factory sheet does not state it. More than one engine code is possible. The fault list shows the faults of each.

Variant data

What is in this version

Factory data

Trim
Athene
Body
hatchback
Fuel
petrol
Transmission
automatic
Engine size
1390 cc
Power
55 kW (75 HP)
Drive
FWD
Production
2001–2005

Factory service interval

The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.

  • Air filter

    • 60,000 km or 4 years

  • Cabin (pollen) filter

    • 30,000 km or 2 years

  • Engine oil and oil filter

    • LongLife30,000 km or 2 years(valid only with LongLife-approved oil)
    • 15,000 km or 1 year

  • Brake fluid change

    • first: 3 years, then 2 years(first change at 3 years, then every two years)

  • Coolant (antifreeze) change

    • first: 193,000 km or 10 years, then 97,000 km or 5 years(G13 / G12++: first change at 120,000 miles or 10 years, then every 60,000 miles or 5 years)

  • Spark plugs, petrol

    • 60,000 km or 6 years
All IV versions

Information, not an expert opinion

We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.

  • A fault on the list does not mean the car you are looking at has it.
  • A fault missing from the list does not mean the model is fault-free. Write-ups are made model by model. Not all of them are done.
  • You decide whether to buy. This is no substitute for an inspection. That needs a workshop and a history check.
Details in the terms