vinkodex.

Volkswagen Touareg 3.2 V6 common faults.

2002–2007, SUV, petrol, 241 HP.

The list covers this version.

What you save stays on this device only. My saves

1 fault write-ups. Important. 2 recalls.

If you know the year, pick it. Faults for other years drop out of the list.

Before you buy

Known faults

1 important faults

Air suspension: cracking air springs and a tired compressor

expensive

The Touareg works with four air springs and one central compressor. The rubber bellows of the air spring cracks over time, the system loses pressure, and the compressor tries to make it up by running more and more, until it burns out. The symptom is typically that the car settles overnight, or stands lopsided.

Show the rest

The fault goes in a circle: the leaking air spring is what kills the compressor, so if only the compressor is replaced, the next one goes too. A full overhaul is four springs plus a compressor plus a dryer, and that is the most expensive routine repair on a Touareg.

What to check

  • Look at the car cold, after standing a night: has it settled
  • Raise it to the highest, then the lowest setting, and time it
  • Listen to the compressor: a unit running long or loudly is already tiring
2 more steps in the write-up

Checklist

Volkswagen Touareg 3.2 V6

First what you would check on any car. Then the faults of this model.

Before you buy

Checklist

The printed sheet starts with what you would check on any car. What you tick stays on this device only.

On every car

Ask the owner

Faults of this model

vinkodex.com · Before you buy it, see what can go wrong.

Official recall2 recallsShow

The manufacturer fixes these for free at a franchised dealer. Ask with the VIN whether it was done.

Most recent: 20 September 2017

17V583000FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMPFUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP20 September 2017 · NHTSA (USA)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2004-2007 Touareg vehicles. These gasoline-powered vehicles have a fuel filter flange that may crack, allowing fuel to leak.

Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy: Volkswagen will notify owners, and dealers will inspect the fuel filter flange for cracks, replacing the flange if cracks are found. If no cracks are found, a protective cover will be installed onto the filter flange. These repairs will be performed free of charge. The recall began March 9, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 20Ai.

The authority's notice

04V592000SEAT BELTSSEAT BELTS15 December 2004 · NHTSA (USA)

CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." ALL THREE REAR SEAT POSITIONS AND THE FRONT PASSENGER POSITION ARE EQUIPPED WITH SEAT BELT RETRACTORS THAT HAVE A LOCKING FEATURE WHICH CONVERTS THE RETRACTOR FROM AN EMERGENCY LOCKING RETRACTOR (ELR) MODE TO AN AUTOMATIC LOCKING RETRACTOR (ALR) MODE FOR THE PURPOSES OF CHILD RESTRAINT INSTALLATION. THE BELT MAY DEACTIVATE THE ALR MODE WITH CERTAIN CHILD RESTRAINTS.

Risk: WHEN INVOLVED IN A CRASH, THE CHILD RESTRAINTS MAY NOT BE PROPERLY SECURED, INCREASING THE RISK OF INJURIES OR DEATH.

Remedy: DEALERS WILL PERMANENTLY INSTALL A 'CLIP' IN EACH OF THE TWO REAR OUTBOARD SEAT BELTS. THE CLIPS WILL PREVENT UNWANTED DEACTIVATION OF THE ALR MODE WITH CHILD SEAT INSTALLATIONS. THE RECALL BEGAN ON APRIL 11, 2005. OWNERS SHOULD CONTACT VW AT 1-800-822-8987.

The authority's notice

Engine and transmission

No engine and transmission for this yet. When they are in, you see them here.

Variant data

What is in this version

Factory data

Trim
—
Body
SUV
Fuel
petrol
Transmission
automatic
Engine size
3189 cc
Power
177 kW (241 HP)
Drive
AWD
Production
2002–2007

Factory service interval

The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.

  • Air filter

    • 60,000 km or 4 years

  • Cabin (pollen) filter

    • 30,000 km or 2 years

  • Engine oil and oil filter

    • LongLife30,000 km or 2 years(valid only with LongLife-approved oil)
    • 15,000 km or 1 year

  • Brake fluid change

    • first: 3 years, then 2 years(first change at 3 years, then every two years)

  • Coolant (antifreeze) change

    • first: 193,000 km or 10 years, then 97,000 km or 5 years(G13 / G12++: first change at 120,000 miles or 10 years, then every 60,000 miles or 5 years)
All 7L versions

Information, not an expert opinion

We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.

  • A fault on the list does not mean the car you are looking at has it.
  • A fault missing from the list does not mean the model is fault-free. Write-ups are made model by model. Not all of them are done.
  • You decide whether to buy. This is no substitute for an inspection. That needs a workshop and a history check.
Details in the terms