vinkodex.5 fault write-ups. 4 important. 8 recalls.
If you know the year, pick it. Faults for other years drop out of the list.
Before you buy
A thin wall of the mechatronics valve body can crack, which causes a loss of pressure. The typical signs: jerking and harsh shifting from 1st to 2nd at low speed, a flashing PRNDS display, then a gear engagement fault, intermittently at first.
What to check
In the EA211 the water pump and the thermostat are one plastic module, and the pump is driven not by the timing belt but by a separate toothed belt behind the exhaust camshaft. There are usually two problems with it: the plastic housing warps or cracks (slow coolant loss, a sweet smell, rising temperature), or the drive belt ages (a chirping noise, then an engine left with no cooling). The housing is particularly sensitive if oil reaches it: for example from a leaking crankcase ventilation. The module has to be replaced whole: dismantling it warps it in itself.
What to check
At the factory the roof drain hoses were fixed to their stubs with only a few spots of adhesive; heat separates them over time, and the water runs onto the headlining. The drains are also narrow and block up easily. The sign is a damp headlining around the A-pillar, or water in the footwell. The maker issued a technical bulletin about it for the 2015 to 2017 Golf and GTI models.
What to check
After startup or while driving a loud clicking, clattering noise comes from behind the dashboard, typically for three to five seconds, at irregular intervals. The actuator motors that move the climate control blend flaps fail. Stripping the dashboard is seven to eight hours of work, so the labour makes up most of the bill.
What to check
The dash shows "Error: Workshop! Only leave vehicle in position P" with an audible warning. The message appears in whatever language the car is set to, for example "Fehler: Werkstatt! Fahrzeug nur in Stellung P verlassen" in German.
The message points at the gearbox, but the fault is not there. A tiny switch sits in the module under the selector lever and signals that the lever is in park (P). Its contact wears and can also burn. That makes the signal unreliable, and the car warns you. The fault codes appear as 617752, P173400 or B116229.
At first it is intermittent. Sometimes the message comes up, sometimes not, so a short test drive easily misses it. Later it becomes permanent, and the gearbox can drop into limp mode.
This fault looks more expensive than it is. The maker released a separate retrofit switch kit for it (5Q0713128A for the black module, 3Q0713128 for the white one), which can be fitted in half an hour. The kit costs 70 to 100 pounds. At a franchised dealer, however, the whole selector lever module sometimes gets replaced, which costs 626 to 1,000 pounds there. So the difference between the two routes is roughly tenfold.
The affected group is post 2013 MQB platform Volkswagen, Audi, Seat and Skoda cars with a DSG gearbox. The switch is in these gearboxes, because that is what these cars have in common. The part itself is not part of the gearbox but of the module under the lever.
What to check
vinkodex.Checklist
First what you would check on any car. Then the faults of this model.
Before you buy
The printed sheet starts with what you would check on any car. What you tick stays on this device only.
The manufacturer fixes these for free at a franchised dealer. Ask with the VIN whether it was done.
Most recent: 24 June 2020
20V372000EQUIPMENT:OTHER:LABELSEQUIPMENT:OTHER:LABELS24 June 2020 · NHTSA (USA)Volkswagen Group of America, Inc. (Volkswagen) is recalling two 2018 Golf GTI vehicles. The VIN printed on the Federal Certification label may not match the actual VIN on the vehicle. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Risk: If the stamped vehicle identification number (VIN) does not match the VIN on the Vehicle Certification Label, owners may be unable to tell if their vehicle is under an important safety recall, possibly exposing them to an increased risk of a crash, fire or injury.
Remedy: Volkswagen will notify owners, and dealers will install a correct certification label, free of charge. This recall began July 9, 2020. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01E7.
INFO/00145/21Safety recallInjuries13 May 2019 · EU Safety GateDefective material may be used in the rear suspension helical springs. As a result, the springs could break, impairing the driving stability and increasing the risk of an accident. The product does not comply with the requirements laid down in the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles
Remedy: Type of economic operator taking notified measure(s): Importer Category of measure(s): Recall of the product from end users Date of entry into force: 13/05/2019
18V464000STEERING:COLUMN LOCKING:ANTI-THEFT DEVICESTEERING:COLUMN LOCKING:ANTI-THEFT DEVICE11 July 2018 · NHTSA (USA)Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2018 Volkswagen Golf and Golf Sportwagen vehicles. The build of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition while the vehicle shift lever is not in "Park." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Risk: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began March 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37L5.
A12/00222/20Safety recallInjuriesno date · EU Safety GateCars initially used for internal purposes of Volkswagen AG might not have been correctly modified before they were sold to the general public. There is a possibility that certain safety systems of these cars are not correctly modified for street use.
Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown
A12/0388/18Safety recallInjuriesno date · EU Safety GateThe brake discs on the front axle are too weak. As a consequence, when placed under extreme pressure, the brake disc can crack or even break, affecting braking performance.
Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown
A12/0774/18Safety recallInjuriesno date · EU Safety GateThe fastening of the active headrest may be defective. In the event of an accident, the headrest may become detached from the back of the seat, increasing the risk of injury to the person occupying the seat.
Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown
A12/1954/18Safety recallInjuriesno date · EU Safety GateThe fitting for the headrest may have been incorrectly welded to the backrest. As a consequence, the supportive and protective effect of the headrest may be limited in the event of an accident.
Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown
SR/00793/25Safety recallInjuriesno date · EU Safety GateThe propellant in the driver airbag may deteriorate over time. If the airbags deploy, it can result in fragments from the inflator injuring the vehicle's occupants. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
Remedy: Type of economic operator taking notified measure(s): Manufacturer Category of measure(s): Recall of the product from end users Date of entry into force: Unknown
Variant data
The manufacturer specifies this for this version. Of the mileage and the time, the one that comes first is the one that counts.
Air filter
DQ200: lifetime fill by the maker, not in practice
Cabin (pollen) filter
Engine oil and oil filter
Brake fluid change
Coolant (antifreeze) change
Spark plugs, petrol
We write the descriptions, and we put the source next to them. A person reviews them before they go out. They are still information, not a technical expert opinion.